Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Calibrationmethod(moredetail)
1) Tum offthe main power
2) Openthe sliding car door half positionby usingthe yellow wheel on the car top
3) Connectthe key-pad(HHT2000)to the "CN7" ofdoor controllerboard
4) Turn on the elevatormain power
5) Pushthe"Resetswitch"(SWl)justonetimeon thedoorcontrollerboard .--. i
6) Checkwhetherthe "RUN LED"(Grcen)"is off is or not
In order to changethe data as "33_SYSTEM_RATIO", ,the RUN LED is ro be "OFF"
Condition
7) Locatethe cursoron "02_PROCRAM ", andpush"ENT" button(onetime)
8) Locatethe cursoron "01-CONTRO|,", andpush"ENT" button(one time)
9) Locatethe cursoron "38-KEYPAD-RUN", andpush"ENT" button(onetime)
l0) Checkthe displayeddatais "ON" or "OFF "' ("ON" shouldbe displayed)
I l) Ifthe cursoris on "OFF', Locatethe cu6or on "ON" and push"ENT" button(onetime)
12) Locatethe cursoron "02-PROGRAM ", andpush"ENT" button(onetime)
l3) Locatethe cursoron "01-CONTROL", andpush"ENT" button(onetime)
l4) Locatethe cursoron"32-CALIBRATION ", andpush"ENT"' button(onetime)
I 5) Locatethe cursoron" l ", and push"ENT" button(onetime)
l6) Then,thecar doorcalibrationis automatically
slarted
(The calibrationprocedureis as below
Speedpattcrnsetting -> Jog speed open --' Jog speed close --+Fullyclose ---
Jog speed open -_' Fully open -,Auto-patternedclose -,Auto mode )
B . Checkagainthe "calibration"is completed
l ) Locatethe cursoron "O2--PROCRAM", andpush"ENT" button(one time)
2) Locatethe cursoron "01-CONTROL", and push"ENT" button(one time)
", "ENT" button(onetime)
3) Locatethe cursoron"32-CALIBRATION andpush
"02" or
Checkthe displayeddatais i0:'
4) 'lfthe displayeddata is "O",it needstb carryout the calibrationag;rin.
("o" meansnot completionofcalibration.)
Ifthe displayeddatais "02", it meanscompletion
ofcalibration
checkthestatusofelevatorsoperf,tion
C . After completionofthe calibration,
l) Pull outthe key-pad(HHT2000)Fromdoorcontroller
2) You canseethe"AUTO/MANUAL" toggleswitchon thecarjLrnclionbox
3) Changethe modeto "AUTO" (automode)
4) Checkthe statusofelevator operatiou