Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2. Mention & explain the factors on which the choice of an electric drive depends.
4. A motor drives two loads. One has rotational motion and coupled to the motor
through the gears with transmission coefficient a=10 and = 90%. Load has
moment of inertia of 10 kg-m2 and torque of 10 N-m. other load has translational
motion and consist of 1000 Kg weight to be lifted upward at the speed of 1.5
m/sec. coupling between this load and the motor has an efficiency of 85%. Motor
has inertia of 0.2 Kgm2 and runs at a constant speed of 1420 rpm. Determine
equivalent referred to motor shaft and equivalent load torque referred tom
motor shaft.
6. Determine the equivalent moment of inertia and equivalent load torque, if loads
are rotational.
10. A drive has the following parameter T = 150 0.1N, N-m and Tl = 100 N-m.
changed to Tl= -100 N-m. Calculate the initial & final equilibrium speed.
11. Explain the intermittent periodic duty & intermittent periodic duty with starting.
12. Assuming that the temperature increase according to exponential law.
Determine the heating time constant for the motor when its temp. rise after 30
13. Explain the method to determine the current rating of motor in the case of
fluctuating load.
14. The temperature rise of a motor when operating for 25 min on full load is 25OC
and becomes 40OC when the motor operates for another 25 min on the same
load. Determine heating time constant & steady state temperature rise.
17. A drive has following parameters: J=10 kg-m2, T=100 0.1N, N-m, passive load
torque Tl=0.05N, N-m Where N is speed in rpm. Initially the drive is operating in
19. Determine the equivalent moment of inertia and equivalent load torque, if loads
are translational.
21. Explain the intermittent periodic duty with starting & breaking and continuous
22. The temperature rise of a motor after operating of 30 min on full load is 20OC.
After another 30 min of operation on same load the temp. rise becomes 30OC.
fluctuating load?
24. A rolling mill driven by the DC motor operates on a reverse duty cycle. Motor
25. A motor equipped with a flywheel as to supply a load torque of 600 N-m. for 10
sec followed by no load period long enough for the flywheel to regain its full load
speed. It is desired to limit the motor torque 450 N-m. What should be the
moment of inertia of flywheel? No load speed of the motor is 600 rpm & it has a
26. A motor has a heating time constant of 45 minutes and cooling time constant of
75 minutes. The motor has final steady state temperature rise of 50oC while
27. Write short notes on the Steady state stability of an electric drive.
28. A motor has a heating time constant of 90 minutes. If the temperature rise of the
motor is 100oC when it is continuously loaded with its rated load. Determine the
temperature rise of the motor after 2 hour of its rated load. If the temperature
after 2 hour reaches the maximum permissible temperature (final steady state
copper loss.
29. Derive the formula for overloading factor, when a motor is subjected to