Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
In order to compensate for the manufacturing tolerance, an initial adaptation for the clutch is
required after:
The adaptation value in the TCU can be wiped off due to long term power disruption. The CVT
check light flashes once every 2 seconds if the initial adaptation is not performed. It is not
recommended to drive the vehicle in such condition to avoid accessive clutch wear.
CONDITIONS
Throughout the procedure
PROCEDURE
*In the case that the CVT check light doesn't go off after this Initial Adaptation procedure is
performed, send the car to the nearest SC to clear the warning.
TCU keeps adapting to compensate for the wear and tear as you use the vehicle. However, due
to the rarity of using certain drive modes (i.e reverse), the TCU may not be able to adapt to every
drive modes. This may result in the 'engine die off' issue while reversing, due to poor clutch lock-
up.
Users can perform the following adaptation procedure periodically to compensate for the wear
and tear.
Adaptation can be performed without additional equipments.
CONDITIONS
Throughout the procedure
PROCEDURE