Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Hyperlast RS l 00 l Polyol .
---+- - -- - - ------
Lot number:
- - - - - - - - - - - - - - _ _ _ _ _ _ _ _ __ _ _ _ _ _
N/ A -
ASTM 04060 - Standard Test Method for Abrasion Resistance of Organic Coatings by
the Taber Abraser.
ASTM 04541 - Standard Test Method for Pull-Off Strength of Coatings Using Portable
Adhesion Testers.
CSA Z245 .20- l 4, Section 12.15 about Gouge Test.
ASTM G 14 - Standard Test Method for lmpact Resistance of Pipeline Coatings (Falling
Weight Test).
ASTM G 17 - Standard Test Method for Penetration Resistance of Pipeline Coatings (Blunt
Rod).
Interna! procedure to evaluate non-shielding properties of the coating.
Electrochemical tests
The following pages show the results obtained by the standards and methodology described
above. ~ 'J ..
.
.-
.
'i'
...
Certified by: Jos Albe o Padilla Lpez-Mndez
NACE Certified Coatings Inspector Leve! 3 # 1535
MECHANICAL PROPERTIES
Table l. Mechanical propertie s of Polyurethan e coat layer.
Test Standard Results
0.123 at 500 cycles
Abrasion resistan ce 1 ASTM 04060 0.753 at 1000 cycles
___
o_.9_8 3 aJ 1400 cvcles
No damage observed in th e
lmpact resista nce (6 J)
AS TM G 14 film that reached the
Thickness = 'h in
substra te
No damage observed in the
lmpact resistance (1 6 J)
AS TM G 14 film that reached the
Thickness = l in
substrate
lmpact resistance 4 (42 J) No damage in the film th] t
ASTM G l 4
Thickness = l .5 in reached the substrate .
- - - -- - - - - ----, - ------- . - -
Penetration resistan ce5 ASTM Gl7 41 3 coating thickness
NOTES:
1Thickness evaluated was 0.5 inches
CP SHIELDING
,
Table 2. CP Shie lding properti es of Po lyurethane c oat layer.
Test
CP Sh' Id' 1 2 G
I 1t
Standard
d tl Results
Does not shield the cathodic
J
l
1e 1ng n erna 1proce ure. protection current applied
Open ~ircuit p-;tentlal and Ele~tr~~hemical - t- d
1n erna 1proce ure
.- P~sence o~harge .transfer
.
lmpedance Spectroscopy 23 thus does not CP Sh1e ld1ng
---- -- - --- - - -----
NOTES:
1Referto individual test procedure .
2Thickness evaluated was l .5 in.
3The conditions were: Electrolyte: NaCI 33 . 65 C. 192 hours of immersion before testing, lnitial
freq=5.00E+03 Hz, final freq=2.00E-02, Points/decade=l.OOE+Ol , AC Voltage (V rms)= l.OOE+Ol and
Sample orea= 3.98 cm2.
_ !. :,.~