Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
0030 X Material Test Reports: of Cast or Heat Analysis, Product analysis Per 02-SAMSS-011 Par. 5.4 and Table 5
and Carbon equivalent
0040 X NDT Procedures and Personnel Verify valid personnel qualification and approved procedure
0020
0010
***
X X
In process inspection & test requirement
Forging operation/process
Specification Details / Notes:
One per PO line item
0020 X X Mechanical Testing: Tensile Test, Impact test and Hardness test 02-SAMSS-011 Par.5.5 and Table 5.
0034 X X Metallographic Examination: Grain Size and Ferrite Content. 02-SAMSS-011 Par. 7 and Table 5
0040 X X Nondestructive Testing: a) Magnetic Particle Testing and Liquid 02-SAMSS-011 Section 9. One per PO line item or 10% Per
penetrant Testing line item which is higher.
0042 X X Nondestructive Testing: b) Ultrasonic Testing 02-SAMSS-011 Par. 9.3. Refer to SAMSS for details and
application of A707, A388, A508 requirements.
0030
0010
***
X
Final inspection & test requirements
Visual and Dimensional Inspection.
Specification Details / Notes:
02-SAMSS-011, the respective ASTM/Industrial Standard and
approved drawings.
IR022501 Continued...
INSPECTION & TESTING REQUIREMENTS REVISION: 07/30/2012 CODE NUMBER: PAGE:
SAUDI ARAMCO FORM-175 REPLACES: 07/15/2012 IR022501 2 of 2
(1) VISUAL INSPECTION WITNESSING BY INSPECTOR (Note 1)
(2) CERTIFICATES / RECORDS TO BE CHECKED BY INSPECTOR
(3) CERTIFICATES / DATA TO BE PROVIDED BY VENDOR / SUPPLIER / MANUFACTURER
0020 X Inspection of Raised Face Gasket Surface 02-SAMSS-011, ANSI B46.l: Surfaces shall have a finish of 3.2
to 6.4 micro-meters Ra
0050 X X Special Flange Dimensions (when applicable) 02-SAMSS-011: Apply the Standard Drawings as referenced in
SAMSS or the approved #Special Design#.
Notes:
(1) May only be waived by the responsible Saudi Aramco, ASC, or AOC Inspection Offices.
(2) See form SA 175 -000003 for instructions on using this form.
(3) Extent of frequency of testing and inspection is per 02-SAMSS-011 Table 3 and Table 4
End of IR022501