Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
This stripe
a. Identifies that the hose is constructed for synthiec rubber and may be suitable for a wide range of
application.
b. Identifies that the hose is for hydraulic fluid only.
c. Is used to ensure that the hose is installed without excessive twisting.
3. Which characteristics apply to aircraft hydraulic system? 1. Minimum maintenance requirements 2. Light
weight 3. About 80% operating efficiency 4. Simple to inspect
a. 1,2,3, and 4
b. 1,2, and 4
c. 1,3. And 4
5. Pressure is a term used to indicate the force per unit area. Pressure is usually expressed in
a. Pound per inch
b. Pounds per square inch
c. Pounds per cubic inch
6. A cross valve which is designed to bypass fluid from one side of an actuating cylinder to the other side, under
certain condition, may be found in some aircraft installed in the
a. Flap overload system
b. Landing gear system
c. Engine cowl flap system
7. To prevent external and internal leakage in aircraft hydraulic units, the most commonly used type of seal is
the
a. O- ring seal
b. Gasket seal
c. Cherrvov seal
9. A rigid tube is too short for the flare to reach its seal before tightening, pulling it into place by tightening
a. May distore the flare
b. Is acceptable
c. May distort the cone
10. In a hydraulic brake system uses neoprene rubber packing materials, the correct hydraulic fluid to service the
system is
a. Mineral base oil
b. Skydrol
c. Vegetable base oil
11. The internal resistance of a fluid which tends to prevent it from flowing is called
a. Volatility
b. Viscosity
c. Acidity
1
a. Nonflammable under all condition
b. Flammable under normal condition
c. Compatible to natural rubber seals and packing
14. Which of the following is adversely affected by atmospheric humidity if left unprotected? 1. MIL-H-5606 2.
SKYDROL. 3. None of the above.
a. 2
b. 1 and 2
c. 3
16. Two types of hydraulic currently being used in civil aircraft are
a. Mineral base, and phosphate ester base
b. Mixed mineral base and phosphate ester base
c. Petroleum base and mixed mineral base
17. Which of the following lists only desirable properties of a good hydraulic fluid
a. High viscosity, low flash point, chemical stability, high fire point
b. Low viscosity, chemical stability, high flash point, high fire point
c. High flash point, low viscosity, chemical stability, low free point
2
3