Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
We thank you very much for purchasing a Waterfall High Force Subwoofer. Our deliberate
choice for aesthetics and performance is constantly guiding our research and development
towards innovative technologies. In order to achieve the best performance with your Home
Cinema system, we recommend you read carefully the following set up instructions.
S300
-
HI-LEVEL INPUT 14 not in use for a while, amplifier goes back into standby, if "On" position
SUBWOOFER
is used, this means the amplifier will continuously be on, and will not go
ATOHM into standby.
Main power 9 24-12-LFE : Switching of the active filter of the Sub. The choice of 24Db
3 switch per octave or 12Db per octave is to be determined through listening
OFF ON (on - off) and personal choice.
O
I
Finalise the complete set up (distance, test tone). Please refer to your A/Vs usuer manual or dealer if you need assistance.
WA RN I N G :
11 LOW LEVEL INPUT
I m po r tant N OTE: 11 LOW LEVEL INPUT
po laritie s have to be
che cke d at all tim e s .
L R DIRECT 1 L R DIRECT 1
DIRECT 2 DIRECT 2
Integrated amplifier + Integrated amplifier +
+ -
speakers B
- + HI-LEVEL INPUT 14 + -
speakers B
- + HI-LEVEL INPUT 14
In both cases, please set up the HF3 IPs amplifier as described below
Freq (N6) on 130 Hz (as shown) if you use Serio, Hurricane Evo or Elora, 60 Hz if you use an Iguasu Evo or Victoria Evo.
-"24-12-LFE" (N9) switch must be on the "12" position,
- Phase (N5) should be on 0 in most of the cases. Phase may be adjusted if necessary.
- Adjust the volume level (N6) to your own choice.
D) Warranty
See Waterfall Warranty Card
This document is to be included in any resale of the product.
www.waterfallaudio.com