Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Dr. N. K. Patel
Lecture: 16 Nitric acid
Module: 4
Lecture: 16
NITRIC ACID
INTRODUCTION
Nitric acid (HNO3), also known as aqua fortis (strong water) and spirit of niter,
is a highly corrosive strong mineral acid. The pure compound is colourless, but older
samples are yellowish in colour due to the accumulation of oxides of nitrogen.
Commercially available nitric acid having concentration of 68% HNO3, while the
solution containing more than 86% HNO3, is referred to as fuming nitric acid.
Depending on the amount of nitrogen dioxide present, fuming nitric acid is further
characterized as white fuming nitric acid or red fuming nitric acid, at concentrations
above 95%.
Glauber invent the process to obtain HNO3 by heating niter with strong sulfuric
acid. In 1776 Lavoisier showed that it contained oxygen, and in 1785 Henry
Cavendish determined its precise composition and synthesized it by passing a
stream of electric sparks through moist air.
MANUFACTURE
NPTEL 96
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
Raw materials
Reaction
Manufacture
Cooled Silica
Pipes
Cast Iron
Retort Water
out
Water in
Stoneware
Balls
Furnace HNO3
Conc. HNO3
Dil. HNO3
Animation
NPTEL 97
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
Equal weight of sodium nitrate (or potassium nitrate) and sulfuric acid is
charged to cast iron retort having outlet provided at bottom to take out solution of
sodium bisulfate. The reactants are heated to about 2000C by the hot furnace
gases. The furnace gases are produced by combustion of coal in the furnace. Then
the vapour of nitric acid are cooled and condensed in water cooled silica pipes.
The cooled acid is collected in stoneware receiver. The un-condensed vapours are
scrubbed with water in absorption tower which is packed with stone ware balls and
cooled by cold water. The dilute acid is re-circulated till it becomes concentrated.
The residual sodium bisulfate is removed by outlet provided at the bottom of retort.
Raw materials
Reaction
Manufacture
Na2CO3
Water
Solution
Cooling
water
Oxidation
Air
Tower
Absorption Soda
Towers Tower
Boiler Na2CO3 Tower
50 % Nitric
Electric Arc Acid
Furnace
NPTEL 98
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
Animation
Air freed from CO2 and moisture is passed through electric arc chamber
having two copper electrodes which are continuously circulated by cold water and
are connected with AC dynamo. A powerful electromagnet placed at right angles
to the electrodes spreads the arc in the form of a disc. The chamber is also provided
with inside suction pumps for rapid circulation of air across the flame through holes
of refractory fire work. Nitrogen and oxygen of air combines at 20000C temperature
to form nitric oxide. The hot exit gases (10000C) leaving the chamber is passed
through tube fire boiler for steam generation. The temperature of gases leaving the
boiler is significantly reduced up to 1500C. The gases are allowed to pass through
oxidation chambers made of iron and lined inside with acid proof stone. Here, nitric
oxide is further oxidizing to nitrogen peroxide in presence of air. The exit gases from
oxidation towers are passed through series of absorption tower filled with broken
quartz through which cold water or dilute nitric acid is continuously sprayed from
top. The gases which enter from the base of 1st tower are leave at the top.
Continuous counter current flow of gases in each tower is maintained by centrifugal
fan. The 3rd tower is fed with cold water and the dilute nitric acid is collected at the
base is re-circulated to the top of the preceding tower. 50% HNO3 is obtained at the
base of 1st tower. The gases leaving the last absorption tower contains traces of
nitrogen oxides. The gases are allowed to pass through two wooden towers which
are sprayed down by dilute solution of soda ash. The solution at the base of sodium
carbonate tower is evaporated to collect crystal of sodium nitrate.
Engineering aspects
Raw Materials
Basis: 1000kg nitric acid (100%)
Ammonia = 290kg
Air = 3000Nm3
Platinum = 0.001kg
NPTEL 99
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
Water = 120000kg
Steam credit = 1000kg @ 200psig
Power = 10-30KWH
Reaction
Major reactions
4NH3 + 5O2 4NO + 6H2O H = - 216.6kcals ---- (1)
2NO+O2 2NO2 H = - 27.1kcals ---- (2)
Side reactions
4NH3 + 3O2 2N2 + 6H2O H = - 302.7kcals ---- (3)
2NH3 N2 + 3H2 H = + 26.7 kcals ---- (4)
2NH3 + 2O2 N2O + 3H2O H = - 65.9kcals ---- (5)
4NH3 + 6NO 5N2 + 6H2O + 432.25kcal H = - 431.9kcals ---- (6)
Nitrous oxide oxidation and absorption
2NO+O2 2NO2 H = - 27.1kcals ---- (7)
3NO2 + H2O 2HNO3+ NO H = - 32.2kcals ---- (8)
2NO2 N2O4 H = - 13.9kcals ---- (9)
2NO2 + H2O HNO3 + HNO2 H = - 27.7kcals ---- (10)
HNO2 H2O + NO + NO2 ---- (11)
Manufacture
Nitric acid is made by the oxidation of ammonia, using platinum or platinum-
10% rhodium as catalyst, followed by the reaction of the resulting nitrogen oxides
with water.
Animation
NPTEL 100
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
Process Steam
Vaporizer
Tail Gas
NH3
storage
Water cooling
Converter Water
800 0C cooling
Absorption
Compresed Super
Tower
preheated air heater
Oxidation
Tower
Heat Tail gas
Recovery heater
Boiler
Steam
Catalyst Economiser
Convertor Recovery Air
Filter Air
Compressed air is mixed with anhydrous ammonia, fed to a shell and tube
convertor designed so that the preheater and steam heat recovery boiler-super
heater are within the same reactor shell. The convertor section consists of 10-30
sheets of Pt-Rh alloy in the form of 60-80 mesh wire gauge packed in layers inside the
tube. Contact time and of the gas passes downward in the catalyst zone
2.5 X 10-4sec and are heated at 8000C.
Product gases from the reactor which contain 10-12% NO, are sent through
heat recovery units consisting of heat recovery boiler, super heater and quenching
unit for rapid cooling to remove large fraction of product heat, and into the oxidizer-
absorber system. Air is added to convert NO to NO2 at the more favourable
temperature (40-500C) environment of the absorption system. The equipment in the
NPTEL 101
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
absorption train may be series of packed or sieve tray vertical towers or a series of
horizontal cascade absorbers. The product from this water absorption system is 57-
60% HNO3 solution which can be sold as or concentrated as follows
Concentration by H2SO4
Rectification with 93% H2SO4 (660Be) in silicon-iron or stoneware tower
produces concentrated nitric acid and 70% H2SO4 which can be re-evaporated to
93% H2SO4 or used as it is.
Concentration by Mg(NO3)2
Magnesium nitrate solution containing 70-75% Mg(NO3)2 is fed to dehydrating
tray along with dilute HNO3 from the absorption tower. The salt solution acts as an
extractive distillation agent, removing water at 1000C or higher, thus allowing
rectification with azeotropic formation. The dilute Mg(NO3)2 solution re-concentrated
by evaporation
Advantages
Operating cost is half compare to H2SO4 process
Acid quality and yield improved
Disadvantage
Increase in 70% capital expenditure
Engineering aspects
All the above exothermic reaction takes place in more or less extent.
Reaction 12 and 13 occurs with decrease in enthalpy with increase in number of
moles followed by increase in entropy.
NPTEL 102
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
Explosion limit
The explosion limits are avoided by employing quantity of air such that the
amount of ammonia mixed with it is less than 10.5vol% of total volume.
Thermodynamics
The thermodynamics of competing reactions (12) and (13) are rendered
unfavourable by working above 5000C, while the reaction (14) are not favoured if
the process is carried out under 12000C
Kinetics
Kinetics of reaction (1) is speeded up by use of catalyst. This is also done by
preventing any reduction in the velocity of the reaction brought about by presence
of inert gas nitrogen in the reaction zone.
NPTEL 103
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
Advantages
Higher acid strength
Lower investment cost
Higher reaction rate and lower volume in both oxidation and absorption
equipment
Disadvantages
Lower oxidation yield
Higher power require if recovery units are not specified
Higher catalyst loss unless good catalyst recovery procedure are not used
The metallic alloy catalyst is prepared into very fine threads of diameter
0.05mm which are woven into meshes with more than 1000stiches/cm2. Two to four
or even more of these meshes are placed on top of one another inside the reactors
when these are put into operation.
Catalyst threads are smooth, bright and less active at initial stage, as the time
progresses they becomes dull and wrinkled whereupon their activity rises to the
NPTEL 104
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
maximum. Finally they become spongy with activity falling off. When it is in most
active state, ammonia oxidation yields up to 98% of NO are obtained.
Catalyst poison
Sulfates, H2S, chlorides, Arsenic and its oxide, Si, P, Pb, Sn and Bi are
permanently poisoning the catalyst. These elements lead to the formation of
inactive compounds in the wires resulting in decreasing of the catalytic activity.
Traces of acetylene, ethylene, Cr, Ni and Fe temporarily reduce the conversion
efficiency which can be restored by treatment with HCl. There so air should be freed
from all above impurities along with suspended particles of lubricants, fats, fine dust
and abrasive powder. Also, suspension of Fe2O3 from ammonia is removed. For that
efficient filtration system along with magnetic separators are provided.
PROPERTIES
Physical Properties
Molecular formula : HNO3
Molecular weight : 63.013gm/mole
Appearance : Colourless liquid
Odour : Pungent
Boiling point : 1210C (68% HNO3 solution)
Melting point : -420C
Density : 1.5129gm/mL (liquid)
Solubility : Miscible with water in all proportions
The impure nitric acid is yellow due to dissolved oxides of nitrogen, mainly
NO2.
It has a corrosive action on skin and causes painful blisters.
Chemical Properties
Acidic properties: It is a strong monobasic acid and ionization in aqueous
solution.
Oxidizing properties: It acts as a powerful oxidizing agent, due to the
formation of nascent oxygen.
Action on metals: It reacts with almost all the metals, except noble metals, like
Pt and Au. The metals are oxidized to their corresponding positive metal ions
NPTEL 105
Module 4
Dr. N. K. Patel
Lecture: 16 Nitric acid
while HNO3 is reduced to NO, NO2. N2O, NH2OH or NH3, depending upon the
conditions such as temperature, nature of metal and concentration of the
acid.
Nitric acid has ability to separate gold and silver.
USES
NPTEL 106