Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
COURSE
LMD 23403
MARINE AUXILIARY SUPPORT SYSTEM 1
ASSIGNMENT 5
FRESH WATER GENERATOR AQUA TYPE
The AQUA Blue fresh water generator consists of single plate pack containing a
These plates are suspended within a frame , frame plate and pressure plate.
Evaporation , separation and condensation all occur in the same plate pack.
Among the plate pack features are gaskets with rubber flaps that indicate correct
plate assembly.
Combined system for a condenser cooling water , feed water and ejector water.
The sea water floes regulated to ensure optimized production and fresh water with
The fresh water system consists of a pump and a fresh water control sensor that
function.
1) Control Panel
To measure pressure.
Control of sea water to the condenser and jacket cooling water to the
evaporation.
Discharge brine
4) Water Clock
6) Vacuum Gauge
9) Salinometer
Prevent whole fresh water from getting contaminated with salt water.
2. Feed water enter the lower ( evaporation ) section of the plate pack , which the plates
3. Water evaporated around 40C - 60C in a vacuum which is maintained by the brine /
air ejector.
4. The vapour produced rises between the plates into the middle ( separator ) section of
the plate pack , where any droplets of entrained sea water are removed. Gravity cause
these droplets to fall back into the brine pump at the bottom of fresh water generator.
5. Only clean fresh water vapour reach the top ( condenser ) section of the plate pack ,
6. The vapour is condensed into fresh water , which is pumped out of the fresh water
generator by the fresh water pump into the fresh water tank.