Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Selection Guide
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Application
Jump
PFC
Power Factor control
Jump
LLC Low noise
Current resonance mode
Jump
PRC Low noise
Fixed OFF Time control
Jump
QR Low noise
Quasi-Resonant mode
Variable frequency control
Jump
PWM Small circuit
Pulse Width Modulation
Fixed frequency control
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Sanken Power Supply IC Series Lineup
PFC Jump
Jump
QR Low noise
Quasi-Resonant mode
Variable frequency control
Jump
PRC Low noise
Fixed OFF Time control
UD
UD
UD UD
UD Jump
PWM Small circuit
UD Low Stand-by Power
Fixed frequency control UD
UD : Under development
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low Standby Power IC New Lineup
Air conditioner UD
UD : Under development
15
Adapter
Maximum No Load Power
Consumption, PIN (mW)
STR3A100
Smart meter
10 Electrical Air conditioner
UD STR4A100 water heater Monitor Laser printer
Charger
Rice cooker Air purifier
5
Vacuum cleaner
UD STR5A100T
0
5 10 15 20 25 30 35 40 45
Maximum Output Power, POUT at AC230V (W)
UD DIP8 SOIC
UD
Preliminary
DIP8
STR3A100 STR4A100 STR5A100T TO-251(low profile)
PIN 15mW PIN 10mW PIN zero ( 5mW)
High heat release design Sense MOSFET(One Chip) Primary Side Sensing
Sense MOSFET(One Chip)
L2
D1 D4 VOUT
T1
VAC
L2 L1
D1 D4 VOUT T1 D3 VOUT
R9 T1
R3 VAC VAC
C5
PC1 R4
C1 C1 C2 C4 R4
P
VDSS=650V C6 R8 C5 R3
PC1 R4
R9 R6 C7
D3 S R5 C8 C1
/700V P
R8 R5 C8 R7
C7 R6 VDSS=700V D3 S
C6
R5 C8
P1
S1
C4 D2
C3
8 7 6 5 U2
R7 C7 R6
D2 R2
D/ST D/ST D/ST
NC D/ST U1 NC
8 7 6 5 U2
C4 U1
STR3A100 GND
NC S/GND
S/GND S/GND S/GND
D2 R2
R7 STR5A164T VDSS=700V GND
S/GND
D
COMP
C2
D/ST
VCC
FB
U1
S/OCP VCC GND FB/OLP GND
STR4A100 D
1 2 3 4 5
C2
1 2 3 4 D1 R3
FB/OLP VCC D/ST
ROCP
No ROCP 1 2 4
C5 C6
R1 D
C3
PC1
R2
C3 PC1
C9 C9
No photo-coupler
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
AC/DC PWM control IC
For Low Standby Power and Small Circuit Application Back to ALL lineup
PWM is the Pulse Width Modulation, Fixed Frequency Control UD : Under development
UD
No Load Power
Series Package Feature Link
Consumption (PIN)
STR-W6000 TO-220F-6L 30mW Brown in/out Jump
STR-A6000 DIP8 Brown in/out Jump
STR-V653 SIP8L Brown in/out Jump
STR-W6000MX UD TO-220F-6L Brown in/out, HVP
25mW Selectable Standby
STR-W6000MV UD TO-220F-6L
Operation Point
Hybrid IC
STR-A6000MX/HX UD DIP8 Brown in/out, HVP
STR2W100D TO-220F-6L Jump
STR3A100 DIP8 10mW~15mW High heat release package Jump
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 30 mW at no load, PWM Off-Line Switching Regulators
TO-220F-6L
No Load Power Consumption (PIN) 30mW
Protection FunctionsOCP/OVP/OLP/TSD
Built-in Brown in/Brown out Function
Lineup
MOSFET Pout Protective Function
Part Number fOSC
VDSS RDS(ON) AC230V Universal OCP OVP OLP TSD
STR-W6051S 3.95 24W 30W
67 Pulse by Auto Auto Auto
STR-W6052S 650V 2.8 60W 40W
kHz pulse Restart Restart Restart
STR-W6053S 1.9 90W 60W
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 30 mW at no load, PWM Off-Line Switching Regulators
STR-W6000 Series Back to PWM lineup
Package Circuit
TO-220F-6L
Pin Assignment
Pin No. Symbol Function
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 25 mW at no load, PWM Off-Line Switching Regulators
Lineup UD
UD : Under development
MOSFET Pout Protective Function
Part Number fOSC PIN
VDSS RDS(ON) AC230V Universal OCP OVP OLP TSD
STR-A6051M 3.95 16W 12W
STR-A6052M 67 650V 2.8 20W 16W Pulse by Auto
Latched Latched <25mW
STR-A6053M kHz 1.9 24W 20W pulse Restart
STR-A6079M 800V 19.2 8W 5W
STR-A6059H 650V 6.0 10W 8W
STR-A6061H 100 3.95 13W 11W Pulse by Auto
Latched Latched <25mW
STR-A6062H kHz 700V 2.8 15W 13W pulse Restart
STR-A6069H 6.0 10W 8W
STR-A6069HD 6.0 10W 8W
STR-A6061HD 100 3.95 13W 11W Pulse by Auto
700V Latched Latched <25mW
STR-A6062HD kHz 2.8 15W 13W pulse Restart
STR-A6063HD UD 1.9 24W 20W
Pulse by Auto
STR-A6069HL UD 100kHz 700V 6.0 10W 8W Latched Latched <15mW
pulse Restart
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 25 mW at no load, PWM Off-Line Switching Regulators
Package Circuit
DIP8
Pin Assignment
Pin No. Symbol Function
1 S/OCP MOSFET Source/OCP
2 BR Brown-in/Brown-out control
3 GND Ground
4 FBOLP Feedback control
Over Load Protection
5 Vcc Power supply input
/Over Voltage Protection
6
7 MOSFET Drain
D/ST Startup current input
8
Features Leading Edge Blanking
No Load Power Consumption (PIN< 25mW) Audible Noise Suppression Function for standby mode
Built-in Random Switching Function Brown-in/Brown-out function
Built-in Startup Circuit Two Chip Structure(MOSFET guaranteed Avalanche Energy)
Bias Assist function (to reduce VCC voltage drop) Protection Functions
Slope Compensation (to prevent Sub-Harmonic oscillations) OLP: Auto restart, built-in delay timer (external capacitor less)
OCP with Built-in Input Compensation Circuit OCP: Pulse by pulse
Auto Standby function (to enable low standby power) OVP/TSD: Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low Profile Package, PWM Switching Power Supply Applications
SIP8L
Low Profile Package
(Height 12mm ,Pin pitch=2.54mm , terminal form is straight)
No Load Power Consumption (PIN) 25mW
Protection FunctionsOCP/OVP/OLP/TSD
Built-in Brown in/Brown out Function
Pulse by Auto
STR-V653 67kHz 650V 1.9 30W 23W Latched Latched
pulse Restart
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low Profile Package, PWM Switching Power Supply Applications
Package Circuit
SIP8L
Pin Assignment
Pin No. Symbol Function
1 D/ST MOSFET Drain
Startup current input
3 S/OCP MOSFET Source/OCP
4 BR Brown-in/Brown-out control
5 GND Ground
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 25 mW at no load, PWM Off-Line Switching Regulators
STR2W100D Series Back to PWM lineup
TO-220F-6L
No Load Power Consumption (PIN) 25mW
Protection FunctionsOCP/OVP/OLP/TSD
Lineup
MOSFET Pout Protective Function
Part Number fOSC
VDSS RDS(ON) AC230V Universal OCP OVP OLP TSD
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 25 mW at no load, PWM Off-Line Switching Regulators
STR2W100D Series Back to PWM lineup
Package Circuit
TO-220F-6L
Pin Assignment
Pin No. Symbol Function
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 10~15 mW at no load, PWM Off-Line Switching Regulators
STR3A100 Series Back to PWM lineup
Back to New lineup
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PIN < 10~15 mW at no load, PWM Off-Line Switching Regulators
STR3A100 Series Back to PWM lineup
Back to New lineup
Package Circuit
DIP8
Pin Assignment
Pin No. Symbol Function
1 S/OCP MOSFET Source/OCP
Hybrid Power IC
No Load Power
Series Package Link
Consumption (PIN)
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Built-in Auto Standby Function, PRC Off-Line Switching Regulators
STR-A6100 Series Back to PRC lineup
DIP8
No Load Power Consumption (PIN) is 40mW
Protection FunctionsOCP/OVP/OLP/TSD
Lineup
MOSFET POUT Protective Function
Part Number t(OFF)
VDSS RDS(ON) AC220V Universal Auto Bias OCP OVP OLP TSD
AC100V AC120V
STR-A6131 3.95
13W 15W
500V
AC100V AC120V
STR-A6132 2.62
8s 16W 18W
Pulse by Auto
STR-A6159 6 13W 10W Yes Latched Latched
pulse Restart
650V
STR-A6151 3.95 15W 13W
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Built-in Auto Standby Function, PRC Off-Line Switching Regulators
STR-A6100 Series Back to PRC lineup
Package Circuit
DIP8
Pin Assignment
Pin No. Symbol Function
1 S/OCP MOSFET Source/OCP
Feedback control
2 VCC /Over Load Protection
3 GND Ground
Feedback control
4 FB /OLP /Over Load Protection
5 Startup Startup current input
6 NC
7
D MOSFET Drain
8
Features
No Load Power Consumption (PIN< 40mW) Leading Edge Blanking
PRC Control (Current mode) Two Chip Structure(MOSFET guaranteed Avalanche Energy)
Built-in Startup Circuit Protection Functions
Bias Assist function (to reduce Vcc voltage drop) OLP: Auto restart
Auto Standby function (to enable low standby power) OCP: Pulse by pulse
OVP/TSD: Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low Profile Package, PRC Off-Line Switching Regulators
STR-V100 Series Back to PRC lineup
Lineup
MOSFET POUT Protective Function
Part Number t(OFF)
VDSS RDS(ON) AC220V Universal Auto Bias OCP OVP OLP TSD
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low Profile Package, PRC Off-Line Switching Regulators
STR-V100 Series Back to PRC lineup
Package
Circuit
SIP8L
Pin Assignment
Pin No. Symbol Function
1 D MOSFET Drain
2
3 S/OCP MOSFET Source/OCP
Feedback control
4 VCC Over Load Protection
5 GND Ground
Power supply input
6 FB/OLP /Over Voltage
Protection
7
8 Startup Startup current input
Features
No Load Power Consumption (PIN< 40mW) Leading Edge Blanking
PRC Control (Current mode) Two Chip Structure(MOSFET guaranteed Avalanche Energy)
Built-in Startup Circuit Protection Functions
Bias Assist function (to reduce Vcc voltage drop) OLP: Auto restart
Slope Compensation (to prevent Sub-Harmonic oscillations) OCP: Pulse by pulse
Auto Standby function (to enable low standby power) OVP/TSD: Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
AC/DC QR control IC
Back to ALL lineup
For Low Noise and High Power Application
QR is the Quasi-Resonant Mode, Bottom ON Switching
Hybrid Power IC
No Load Power
Series Package Link
Consumption (PIN)
STR-G5600 TO-220F-5L Jump
0.3W(AC100V)
STR-Y6700 TO-220F-7L Jump
0.5W(AC240V)
STR-L6400 SIP10L 0.1W Jump
Controller
No Load Power
Series Package Link
Consumption (PIN)
30mW(AC100V)
SSC1S310 SOIC8 Jump
50mW(AC240V)
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Quasi-resonant (QR) Off-Line Switching Regulators
STR-G5600 Series Back to QR lineup
TO-220F-5L
Light load action is QR
Protection FunctionsOCP/OVP/OLP/TSD
Lineup
MOSFET POUT Protective Function
Part Number
VDSS RDS(ON) AC100V AC120V OCP OVP OLP TSD
Universal
STR-G5653 650V 1.9 125W
60W
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Quasi-resonant (QR) Off-Line Switching Regulators
STR-G5600 Series Back to QR lineup
Package Circuit
TO-220F-5L
Pin Assignment
Pin Symbol Function
No.
1 D MOSFET Drain
2 S MOSFET Source
3 GND Ground
Feedback control
4 VIN Over Load Protection
5 OCP/FB OCP/Feedback control
Features
Light Load action is PRC Control Two Chip Structure(MOSFET guaranteed Avalanche Energy)
Built-in Startup Circuit Protection Functions
Built-in Step drive circuit OCP: Pulse by pulse
Built-in Constant voltage drive circuit OVP/TSD: Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Low Profile Package
Quasi-resonant (QR) Off-Line Switching Regulators
STR-L400 Series Back to QR lineup
Lineup
MOSFET POUT Protective Function
Part Number
VDSS RDS(ON) AC100V AC230V OCP OVP OLP TSD
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Low Profile Package
Quasi-resonant (QR) Off-Line Switching Regulators
STR-L400 Series Back to QR lineup
Package Circuit
SIP10L
Pin Assignment
Pin No. Symbol Function
1
2
D MOSFET Drain
3
4
5
6 S MOSFET Source
7 GND Ground
Feedback control
8 VIN Over Load Protection
9 OCP/FB OCP/Feedback control
10 GND GND
Features
Light Load action is PRC Control Two Chip Structure(MOSFET guaranteed Avalanche Energy)
Built-in Startup Circuit Protection Functions
Built-in Step drive circuit OCP: Pulse by pulse
Built-in Constant voltage drive circuit OVP/TSD: Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Quasi-resonant (QR) Off-Line Switching Regulators
STR-Y6400 Series Back to QR lineup
TO-220F-7L
Auto Standby function
No Load Power Consumption (PIN) is 0.1W
Auto Burst Function(1 or 2skip)
Protection FunctionsOCP/OVP/OLP/TSD
How to stop OLP can be chosen by Latch or Auto restart
Lineup
MOSFET POUT Protective Function
Part Number
VDSS RDS(ON) AC100V AC240V OCP OVP OLP TSD
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Quasi-resonant (QR) Off-Line Switching Regulators
STR-Y6400 Series Back to QR lineup
Package Circuit
TO-220F-7L
Pin Assignment
Pin No. Symbol Function
D/Startup MOSFET Drain / Start-up current
1 input
2 S/GND MOSFET Source / Ground
VCC Input of power supply for control
3 circuit
Constant voltage control signal
4 FB input / Standby control input /
OLP signal input
BD QR signal input /
5 Over current compensation input
OCP OCP pulse input /
6 Bottom-skip signal input
Soft start control /
7 ADJ Bottom-skip delay time control /
Remote ON/OFF signal input
Features Auto Standby function (to enable low standby power)
No Load Power Consumption (PIN< 0.1W) Leading Edge Blanking
Multi-mode control ON/OFF control by remote signal
Built-in Auto burst Function(Bottom skip:1 or 2skip) Protection Functions
Built-in Startup Circuit OLP: Latch shutdown or Auto restart
OCP with Built-in Input Compensation Circuit OCP: Pulse by pulse
OVP/TSD: Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, PIN is 30mW
Quasi-resonant (QR) Off-Line Switching Regulators
STR-Y6700 Series Back to QR lineup
TO-220F-7L
Auto Standby function
No Load Power Consumption (PIN) is 30mW(AC100V)
Auto Burst Function(1skip)
Protection FunctionsOCP/OVP/OLP/TSD
How to stop OLP can be chosen by Latch or Auto restart
Lineup
MOSFET POUT Protective Function
Part Number
VDSS RDS(ON) DC380V Universal OCP OVP OLP TSD
AC100V
STR-Y6735 500V 0.8
120W
STR-Y6753 1.9 100W 60W
650V
STR-Y6754 1.4 120W 67W Pulse by Latched/
Latched Latched
pulse Auto Restart
STR-Y6763 3.5 80W 50W
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, PIN is 30mW
Quasi-resonant (QR) Off-Line Switching Regulators
STR-Y6700 Series Back to QR lineup
Package Circuit
TO-220F-7L
Pin Assignment
Pin No. Symbol Function
MOSFET Drain
1 D/ST / Start-up current input
MOSFET Source / OCP pulse
2 S/OCP input
Power supply input
3 VCC /Over Voltage Protection
4 GND Ground
Feedback control
5 FB/OLP /Over Load Protection
Bottom Detection Signal Input
6 BD / Input Compensation
Detection Signal Input
7 NF
SIP10L
QR Control IC
Auto Standby function
No Load Power Consumption (PIN) is 0.1W
Auto Burst Function(1 or 2skip)
Protection FunctionsOCP/OVP/OLP/TSD
How to stop OLP can be chosen by Latch or Auto restart
Low Profile Package
(Height 12mm ,Pin pitch=2.54mm , terminal form is straight)
Lineup
MOSFET POUT Protective Function
Part Number
VDSS RDS(ON) AC100V AC240V OCP OVP OLP TSD
Pulse by Latched/
STR-L6472 850V 6.5 15W 25W Latched Latched
pulse Auto Restart
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Low Profile Package
Quasi-resonant (QR) Off-Line Switching Regulators
STR-L6400 Series Back to QR lineup
Package Circuit
SIP10L
Pin Assignment
Pin No. Symbol Function
MOSFET Drain / Start-up current
1 D/Startup input
2 S/GND MOSFET Source / Ground
Power supply input
3 VCC /Over Voltage Protection
Feedback control
4 FB /Over Load Protection
Bottom Detection Signal Input
5 BD / Input Compensation Detection
Signal Input
OCP pulse input /
6 OCP Bottom-skip signal input
Soft start control /
7 ADJ Bottom-skip delay time control /
Remote ON/OFF signal input
Features
No Load Power Consumption PIN<0.1W OCP with Built-in Input Compensation Circuit
Multi-mode control Leading Edge Blanking
Built-in Auto burst Function(Bottom skip:1 or 2skip) Protection Functions
Auto Standby function (to enable low standby power) OLP : Latch shutdown or Auto restart
Built-in Startup Circuit OCP : Pulse by pulse
OVP/TSD : Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Quasi-resonant (QR) Off-Line Switching Regulators
STR-X6700 Series Back to QR lineup
TO-3P-7L
QR Control IC
Have a wide choice of variations
Protection FunctionsOCP/OVP/OLP
How to stop OLP can be chosen by Latch or Auto restart
Lineup
MOSFET POUT Bottom Protective Function
Part Number Auto Burst
VDSS RDS(ON) AC220V Universal Skip OCP OVP OLP TSD
AC100V AC120V
STR-X6729 450V 0.189 No No
/280W /360W
AC100V AC120V
STR-X6737 500V 0.36
/220W /290W
STR-X6756 0.73 300W 150W Yes 1Skip
650V
STR-X6757 0.62 260W 120W
STR-X6769 800V 0.66 250W 110W Latched
STR-X6757N 0.62 260W 120W Pulse by /
650V Latched
STR-X6759N 0.385 No 1Skip pulse Auto
Restart
STR-X6768N 800V 1.0
STR-X6750B 650V 0.62
STR-X6759B 650V 0.385 No No
STR-X6769B 800V 0.66 250W
STR-X6750F 0.62
650V Yes No
STR-X6759F 0.385
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Quasi-resonant (QR) Off-Line Switching Regulators
STR-X6700 Series Back to QR lineup
Package
TO-3PF-7L
Circuit
Pin Assignment
Pin No. Symbol Function
1 D MOSFET Drain
2 S MOSFET Source / Ground
3 GND Ground
Power supply input
4 VCC /Over Voltage Protection
Soft start control /
5 SS/OLP Over Load Protection
6 FB Feedback control
OCP pulse input /
7 OCP/BD Bottom-skip signal input
Features
OCP with Input Compensation Circuit Protection Functions
OLP : Latch shutdown or Auto restart
OCP : Pulse by pulse
OVP : Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Quasi-resonant (QR) Off-Line Switching Regulators
SSC1S310 Series (Controller) Back to QR lineup
Controller
Function
Series PKG Brown DT fMAX Auto Reset RC External Link
/fMIN FMAX(SS)(3)
in/out control Burst Detect Latch Latch
300kHz
SSC9522S SOP18 Auto /28.3kHz Jump
340kHz
SSC9526S SOP18 Auto(1) /30.5kHz Jump
300kHz
SSC9527S SOP18 Fix /28.3kHz(2) Jump
Notes;
(1) In heavy load, dead time fixed 350ns(TYP)
(2) Adjustable minimum frequency
(3) Soft start maximum frequency
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Half bridge topology LLC Off-Line Switching Regulators
SSC9522S Controller Back to LLC lineup
2 VCC 11 VGL
Q(H)
R5 VB 16
VGH C11 D3 T1
REG
RA(H)
RGS(H)
3 FB 12 (NC)
8 D4
R6 15
VS
PC1
4 GND 13 (NC)
VSEN RB(L) DS(L)
1 SSC9527S Q(L) C15
11
VCC VGL Cv
5 CSS 14 VB
2 RA(L)
C10 GND
RGS(L)
Ci D5
4
6 OC 15 VS FB CSS OC RC
RC COM 10
R7 C9 3 5 6 7
R13 C12
7 RC 16 VGH R1 R2
R11
8 Reg 17 (NC) CVCC
C7 PC1 C6 C8 C13 C14
ROCP
C16
9 RV 18 (NC)
Power supply
Features
Built-in floating drive circuit for High-side MOSFET Built-in Brown-InBrown-Out Function
Built-in Soft Start Function External Latch Function
Uncontrollable Operation Detection Function on pulse-by- Protection Functions
pulse basis OCP : Three steps protection corresponding to over current levels
Automatic Dead Time Adjustment Function OLP /OVP/TSD: Latch shutdown
Auto Burst Function
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Half bridge topology LLC Off-Line Switching Regulators
SSC9526S Controller NEW Products Back to LLC lineup
3 FB 12 (NC)
R6 VS
PC1
VSEN RB(L) DS(L)
SSC9526S
4 GND 13 (NC)
1 Q(L) C15
11
VCC VGL Cv
2 RA(L)
5 CSS 14 VB C10
4
GND
COM
RGS(L)
Ci D5
10
6 15 VS
FB CSS OC RC
RC RV
OC R7 C9 3 5 6 7 9 CRV
C12
7 RC 16 VGH R1 R2
R11
8 Reg 17 (NC) CVCC
C7 PC1 C6 C8 C13 C14
ROCP
C16
9 RV 18 (NC)
Power supply
Features
Built-in floating drive circuit for High-side MOSFET Built-in Brown-InBrown-Out Function
Built-in Soft Start Function Reset detect function
Uncontrollable Operation Detection Function on pulse-by- External Latch Function
pulse basis Protection Functions
Automatic Dead Time control Function OCP : Three steps protection corresponding to over current levels
(In heavy loads, fixed 350ns(TYP)) OLP/OVP/TSD : Latch shutdown
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Low noise, Half bridge topology LLC Off-Line Switching Regulators
SSC9527S Controller NEW Products Back to LLC lineup
2 VCC 11 VGL
VB C11 D3 T1
VGH
REG
RA(H)
RGS(H) D4
8
15
3 FB 12 (NC)
R6 VS
PC1
VSEN RB(L) DS(L)
SSC9527S
4 GND 13 (NC)
1 Q(L) C15
11
VCC VGL Cv
2 RA(L)
5 CSS 14 VB C10
4
GND
RGS(L)
Ci D5
FB CSS OC RC
RC COM 10
6 OC 15 VS R7 C9 3 R13 5 6 7
C12
7 RC 16 VGH R1 R2
R11
9 (NC) 18 (NC)
Power supply
Features
Built-in floating drive circuit for High-side MOSFET Built-in Brown-InBrown-Out Function
Built-in Soft Start Function Reset detect function
Uncontrollable Operation Detection Function on pulse-by- Protection Functions
pulse basis OCP : Three steps protection corresponding to over current levels
Fixed dead-time 0.3s(TYP) OLP/OVP/TSD : Latch shutdown
Adjustable minimum frequency
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
PFC control IC Back to ALL lineup
Controller UD
UD : Under development
SSC2005 UD SOIC8
CRM(Critical Conduction Mode)
SSC2006 UD SOIC8
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Interleaved DCM Operation , Power Factor Control IC
SSC2100S Controller Back to PFC lineup
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
CCM Operation, Power Factor Control IC
SSC2001S Controller Back to PFC lineup
C1
1 GND Ground R8 Q1
C2
FMD series
FMX series
CCM Mode Fast Recovery Diode Jump
FMXA series
FMXK series
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
VF1.3V, Low VF Diode for PFC (DCM and CRM Operation)
FMN / FMNS Series Back to PFC lineup
Package
TO-220F-2L TO-3P-2L TO-220F-3L TO-3P-3L
Low VF Diode
VF = 1.30V(max)
VRM = 600V
trr 200ns
UD : Under development
UD
IFSM(A) VF IR(A)/
VRM IF (AVG) Part trr (ns)
10ms PKG. VF(MAX) H.IR(mA)
(V) (A) Number IF(A) IFIR=11
Half-wave (V) (VR=VRM)
5 FMN-1056S 60 1.30 5 505 100
TO-220F
10 FMNS-1106S 100 1.30 10 10010 100
-2L
20 FMN-1206S UD 150 1.30 20 20020 150
TO-3PF
600 30 FMN-3306S UD 150 1.30 30 20020 200
-2L
TO-220F
10 2 FMN-2206S 150 1.30 10 10010 100
-3L
TO-3PF
15 2 FMN-4306S 150 1.30 15 15010 150
-3L
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Trr50ns, Fast Recovery Diode for PFC (CCM Operation)
FMX / FMD Series Back to PFC lineup
Package
TO-220F-2L TO-220F-3L TO-3P-3L
Fast Recovery Diode
VRM = 600V
trr 50ns
UD
UD : Under development
IFSM(A) VF IR(A)/
VRM IF (AVG) Part trr (ns)
10ms PKG. VF(MAX) H.IR(mA)
(V) (A) Number IF(A) IFIR=11
Half-wave (V) (VR=VRM)
5 FMX-G16S 50 1.5 5 5015 30
8 FMXK-1086S 100 TO-220F 1.75 8 306 27
FMXA-1106S 100 -2L 1.98 10 10030 28
10
FMX-1106S 100 1.60 10 5015 30
600 FMXK-2206S 100 TO-220F 1.75 10 10010 27
FMXS-2206S 100 -3L 1.60 10 5015 30
10 2 FMXA-4206S UD 100 1.98 10 10030 28
TO-3PF
FMX-4206S UD 100 1.50 10 10020 30
-3L
FMD-4206S 100 1.70 10 1000.3 50
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
SARS, Diode for Snubber
Using FLR Diode Using SARS
Snubber Snubber Discharge loop
VAC VAC
When MOSFET turns off, the serge current is through When MOSFET turns off, the serge current is through
Serge Absorb loop . It is absorbed by capacitor. Serge Absorb loop . It is absorbed by capacitor.
The electrical charge of capacitor is discharged When SARS is used, the electrical charge of capacitor is
through Discharge loop . The power is not transferred discharged through Discharge loop in recovery period
to the secondary side. Thus it become the loss. of SARS. This power is transferred to the secondary side.
When this capacitor is discharged, the recovery current When this capacitor is discharged, the recovery current of
of diode is flowing into the MOSFET. FLR (Fast Recovery diode is flowing into the MOSFET. Include the inductance
Diode) is used in order to achieve the damage control of in series with SARS in order to achieve the damage
MOSFET . control of MOSFET. (Patented circuit)
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927
Improve Circuit Efficiency Snubber System
SARS, Diode for Adjunct Switch Buck to PFC lineup
Package
SJP TO-220F-2L Axial-2.7mm/0.60mm Improve Circuit Efficiency Snubber System
VRM=800V
X/Y/Z
= 4.5 : 2.6 : 2.15
Axial-4.0mm/0.78mm
Unit : mm
IFSM VF
Part IF trr
Type VRM 50Hz VF Package
Number (AVG) Half-wave IF IFIR=11
(max)
External
SARS02 800V 1.5A 100A 0.92V 1.5A 2 to18 Axial-4.0/0.78
resistance
SARS05 800V 1A 30A 1.05V 1A 2 to 18 SJP(SMA:4.52.6)
Built-in TO220F-2L
SARS10 800 0.3A 1.5A 13V 0.5A 1 to 9
resistance(22)
Power Electronics for Next "E" Stage Expansion / Evolution / Eco-Solutions 120927