Sei sulla pagina 1di 3

All dimensions in mm

Cutting shall preferably be done with plasma or water jet. General tolerance on dimensions 0.1mm
Edges are prepared to level P2 (removing of cutting edges) Material DH36 or S355 or S275 steel
refer to ISO 8501-3. Quantity 130 off
Finished samples should be square and flat to within 0.3mm.

100

200 3

Standard test sample plate


Drawing No R&T SU-01 Not to scale
Date - 10/10/2016
madan.pal@baesystems.com Third angle projection
All dimensions in mm
Cutting shall preferably be done with plasma or water jet. General tolerance on dimensions 0.1mm
Edges are prepared to level P2 (removing of cutting edges) Material DH36 or S355 or S275 steel
refer to ISO 8501-3. Quantity 20 off
Finished samples should be square and flat to within 0.3mm.

Butt Weld Guidance

Plain bevel end


preparation

200

Prefab, a gap approx. 3-4 mm should be


created to obtain a proper weld penetration

correct preparation and right gap to


create a proper penetration

Standard butt weld test sample


3
Drawing No R&T SU-02 Not to scale
15 15
Date - 10/10/2016
madan.pal@baesystems.com Third angle projection
All dimensions in mm
Cutting shall preferably be done with plasma or water jet. General tolerance on dimensions 0.1mm
Edges are prepared to level P2 (removing of cutting edges) Material DH36 or S355 or S275 steel
refer to ISO 8501-3. Quantity 2 off
Finished samples should be square and flat to within 0.3mm.

300

300 10

US antifouling test sample plate


Drawing No R&T SU-03 Not to scale
Date - 10/10/2016
madan.pal@baesystems.com Third angle projection

Potrebbero piacerti anche