Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Features:
Visteons Electronic Throttle Body features:
! Low torque ripple DC motor - impacts settling ! Default plate angle can be set up to suit customer requirements eight
time and steady state control (8)degrees above closed plate airflow setting
! Dual Throttle Position Sensor - to provide ! Zero hysteresis (improves position control in and around the default
feedback to a Powertrain Control Module position)
! Dual return spring
Benefits:
! Simplifies vehicle packaging
! Enhances ability to improve vehicle emissions
! Enhances ability to improve driveability
! Enhances ability to improve fuel economy over
conventional systems
! Key life Testing
! Durability
! Design verified at the vehicle level
Specifications and descriptions contained in this document were in effect at the time of publication. Visteon reserves the right to discontinue any equipmentorchange PS-2044-2M-0200
specifications without notice and without incurring obligation. (2/00)
Electronic Throttle Body
Performance Characteristics:
! Maximum shaft torque at 25C (Vbatt greater than 8V): ! Maximum Time Delay <31 mS
291 in-oz (2.04 Nm) ! Rise Time (for step size greater than 1) <80 mS
! FMVSS 124 returnability at -40C : <500mS ! Rise Time (for step size less than 1) <100 mS
! Atmospheric Pressure: 60 to 100 kPa ! Setting time <150 mS
! Relative Humidity: 0 to 100% RH
Visteons Electronic Throttle Body should be mounted such that the throttle shaft is more than 45 degrees away from
horizontal. It is considered beneficial to also mount the throttle body with the bore more than 3 degrees from
horizontal to allow water buildup to seep away from the throttle shaft.
In-Line Parallel
W1 = Throttle Position Sensor Output 1
W2 = Throttle Position Sensor Output 2
GND = Ground
(+) = Throttle Position Sensor Voltage (V-Ref)
M(-) = Motor Negative Terminal
M(+) =Motor Positive Terminal
Connecting Cable Requirements
! All wires shall be rated for 135C ambient or
greater, for underhood installation
! All wires shall be 18 AWG
! M+ and M- twisted pair
! W1, GND, (+), W2 twisted bundle
Specifications and descriptions contained in this document were in effect at the time of publication. Visteon reserves the right to discontinue any equipmentorchange PS-2044-2M-0200
specifications without notice and without incurring obligation. (2/00)