Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
e-mail: pendhrisandeep@gmail.com
e-mail: kordesnehal@rediffmail.com
e-mail: sutarsandesh@gmail.com
Abstract :
Due to prominent increase in deforestation for industrial development and outlet of waste
fluid and flue gases from industries has increased GLOBAL WARMING. The system of
purification of industrial waste water via treated flue gases prove advantageous in improving
GREEN TECHNOLOGY .Thus we can able to treat the flue gases and using the same flue
gas for the treatment of industrial waste water.The CO2 is absorbed from flue gases which
undergoes demolecularization. Demolecularization of carbon dioxide involves conversion of
CO2 to CO by electric potential and demolecularization of CO with hydrogen to form carbon
and water. Carbon thus produced can be dried and powdered to form activated carbon. This
activated carbon can be used for the treatment of industrial effluent waste water.
Ativated carbon.
INTRODUCTION:
Forests are the treasures of our earth. But, man started to destroy forests and the
scientists are giving call to save forest. By cutting trees the temperature will raise
enormously, which causes harm to the whole mankind. Due to prominent increase in
deforestation for industrial development and outlet of waste fluid and flue gases from
industries has increased GLOBAL WARMING. So we are in condition to tackle the problem
of global warming which leads to blindness, skin cancer, etc. Nowadays we are carrying
mineral bottles along with us, in future we have to carry oxygen cylinders. In the air, the
carbon dioxide content should be 330 ppm (parts per million).
WORLD SITUATION DUE TO INCREASE IN CO2:
1.The global warming will lead to changes in the rainfall pattern in many areas ,thereby
affecting the distribution of vector borne disease like malaria, filariasis, elephantiasis etc.,
2. A rapid shrinking of the world's glaciers and polar ice caps is occurring.
3. A rise in sea levels is occurring as the ice and snow melt. You may not see this effect of sea
level rise where you live, but down here in Louisiana, it is very apparent if you go into the
marsh.
4. Due to glacier and ice cap melting in the northern hemispheres, the water of the North
Atlantic has become much fresher in terms of salinity. "So what," you say. The Gulf Stream
requires very salty water in the Arctic ocean sinking and flowing south for the system to work
properly. The system may not work if Arctic water loses too much of its salinity. While such
an event would not destroy civilization as we know it, it would put a few kinks in it for those
living on the affected coasts.
5. Agriculture crop yields have decreased in some instances. Some think a significant
decrease in corn crop yields has already occurred. Just when we were counting on surplus
corn crops to produce ethanol fuel.
6. Violent weather is more frequent and unpredictable. The number of hurricanes occurring
each year is forecast to increase and the storms will be more violent. Some experts say this
happened in 2005 as New Orleans and the Gulf Coast were devastated.
INDUSTRIES THAT EMITS CO2:
Industries are one of the major responsible for pollution especially air and water
pollution. Carbon dioxide is main responsible for global warming. Some of the
major industries leaving out carbon dioxide are as follows,
Cement and lime industry, which gives out carbon dioxide durig calcinations and
roasting.
Chloro-alkali industry, on manufacturing soda ash, caustic soda and chlorine gives out
carbon dioxide.
Gelatin and other bio industries, which removes carbon from organic raw material
gives out carbon as carbon dioxide.
Petroleum industry, on cracking of crude oil leaves out enormous amount of carbon
dioxide.
Thermal and coal power plant produces enormous amount of carbon dioxide during
generation of electric power.
Also many other industries which applies combustion process to generate heat
evolutes flue gases. The CO2 content of flue gases depend on the fuel properties.
Coal generates 18-20% CO2 (and up to 30 wt-% ash), natural gas can vary from 2 to
30% CO2, with a pipe line specification limit of up to 3% CO2
Thus we comes to conclusion that green house gas carbon dioxide is main responsible for
global warming. Industries are major responsible for carbon dioxide emission. So Carbon
dioxide evolved from industries can be controlled by demolecularization method.
PROCESS DESCRIPTION:
The principle steps involved in this process are
FLOWSHEET:
We use alkaline solution to absorb the carbon dioxide from the flue gases. On analysis
we conclude that calcium hydroxide (slaked lime) is one of the best absorbers of carbon
dioxide. Calcium hydroxide is stored in absorption column as batch-wise process. Then flue
gases is send into the absorption column where carbon dioxide alone is captured and
absorbed by the calcium hydroxide. Since calcium hydroxide is very good absorber of carbon
dioxide, it does not include the absorption of any other constituents of flue gases such as SO2,
H2S, etc. Flue gases are allowed into the absorption column till the complete conversion of
calcium hydroxide into calcium carbonate. The calcium carbonate formed is then sent into the
calciner.
Calcium carbonate is introduced into calciner, which is 3-8 metres in diameter and
10-25 metres high. It is lined with refractory brick and covered with sheet steel outside for
strength and prevention of gas leakage. Temperature of 8250C is maintained in the calciner
chamber by means of hot gases. At this temperature calcium carbonate decomposes to
calcium oxide (CaO) and carbon dioxide (CO2).
The calcium oxide thus formed is separated and sent to the lime slaker where it mixes
with water to form calcium hydroxide (Ca(OH)2) at 1500C. Thus calcium hydroxide is
recovered back. This recycled calcium hydroxide can be used again and again for absorption
of carbon dioxide from flue gases. So it is a batch-wise process.
DEMOLECULARIZATION OF CO2 :
STEP 1:
Carbon dioxide is then sent to electrolytic chamber, where carbon dioxide is
converted to carbon monoxide (CO) by treating with steam.
Hightemperaturecellsareveryefficientcomparedwithotherelectrolysismethods
astheyproducemoreoxygenandcarbonmonoxidefromagivenamountofelectricity.This
isbecauseathightemperatureswaterandcarbondioxidecanbesplitintosynthesisgas
(hydrogen+carbonmonoxide)andoxygenusingtheheat,andtheSOEC*cellisthereby
selfcooling:Theheatwhichisinevitablyproducedwhenelectricityrunsthroughsomething
thisisneededfortheelectrolyticprocess.
Moreover,itispossibletoutilisetheheatwhichisoftenavailableassurplusheat
from,forexample,powerstationsandindustry.Thiscanbeachievedbyhighelectric
potentialof1520Kw.*(SOECSOLIDOXIDEELECTROLYTICCELL)
CO2+H2OH2+CO+O2
CO2 CO + O2-
H2O H+ + OH-
OH- + O2- + H+ O 2 + H2
STEP 2:
Then carbon monoxide and hydrogen virtually reacts at very increased temperature to
give carbon and water. This can achieved by increasing the temperature to1500K and at high
electric potential.
CO + H2 C + H2O
Carbon thus produced can be dried and powdered to form activated carbon. This activated
carbon can be used for the treatment of industrial effluent waste water.
The carbon produced can be converted into useful products in many ways.
One is carbonic acid (H2CO3).
The carbonic acid, formed as a result of the reaction is released in to the earth
via artificial root system. The carbonic acid absorbed by the soil. Products for pest and
disease control of the plant, the metabolism of plants is specifically stimulated and
encouraged so that storage in the plants of surplus nutrients is avoided and their health and
resistance is improved.
The effluent, coming out from the biological treatment plant, is mixed
with carbon which comes via artificial root in a content-aeration tank. After some
time, the water is allowed to store in a clarification tank, where the carbon particles
get settled at the bottom of the tank. Since the carbon particles are very fine, a
coagulant such as polyelectrolyte is added to aid the removal of the carbon particles.
The spent carbon is regenerated by passing it into the regenerating column and is
used again for the process. Finally the water is filtered by passing it through the
filtration column.
Thus this method gives good air and useful products of carbon like carbonic acid
as good manure for soil and in water treatment which will give pure water. It is a simple and
cheapest method to save earth from global warming. Also it is the best method to control
carbon dioxide emission from industries.
REFERENCES
Bullis, K. (2009, October). Capturing carbon dioxide through cement
production. Technology Review, 112(5)
E.S., Yeh, S., Hounsell, D.A., and Taylor, M.R., Experience curves for
power plant emission control technologies, Int. J. Energy Technology
and Policy, Vol. 2, Nos. 1/2, 2004