Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
46. Each receptacle for towels, paper or waste in toilets of a/c should be constructed
a. of material resistant to fire
b. of material like steel which does not catch fire
c. of material which are self extinguishing type
d. any of the above
47. The routine inspection mentioned on the log book may be identified by
a. identification number mentioned on the front page of log book
b. identification code mention on the preface of log book
c. identification number mentioned on the routine inspection schedule
d. any one of the above
49. Flight time of helicopter means total time from the movement
a. the rotor blade start turning until the moment it finally comes to rest at the end of flight
and rotor blades are stopped
b. the rotor blade is set for collective pitch to take off and till it is set to neutral at touch down
c. hovering to touch town
d. any one of above
50. Mark the correct statement (Passenger safety information card)
a. make use of symbology to convey instruction
b. as in (a) and included use of evacuation slides
c. as in (b) and also show restrictions on smoking
d. none of the above
52. MTCS
a). stand alone airborne GPS equipment may be installed as most required equipment
b). stand alone airborne GPS equipment may be installed on a No hazard, no interference basis
c). no approval is required for installing stand alone GPS equipment
d). none of above
54. Which of the following manual most often used to help ensure EMC during maintenance
a). maintenance manual b). wiring diagram manual
c). component maintenance manual d). all of above
77 An independent aircraft equipment designed to detect potential conflicting aircraft that are equipped with
SSR transponder:
a). TCAS b). ACAS c). both (a) and (b) d). none
78 From.. all aeroplanes shall be equipped with a pressure altitude reporting transponder:
a). 1st Jan. 99 b). 1st July, 99 c). 1st June, 99 d). none of above
81 Guide lines for preparing installation check schedule for radio equipment is given in:
a). BCAR section R b). FAA AC 43 AC 13
c). CAR Section R d). Both (a) and (b) are correct
83 The tolerance and least count on the various test equipment must be:
a). as recommended by manufacturer b). in no case more than the equipment tested
c). as recommended in operational manual d). both (a) and (b)