Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
9 testing
Findings
Based on the testing, the proponents found out that if the tags passes through the
readers at the same time, there was a 1% difference in time, and also the reader can still
read tag from the vehicle even if the vehicle changes path from one lane to another.
The readers can read the tags at the same time but there was a slight difference in time
The system can still read the tag from a vehicle even if the vehicle changes path from one
Findings
When the proponents tested each materials or device, there was a hard time in
testing the RFID reader, it didnt work and the led indicator is blinking. So the proponents
searched and looked for possible solution and found out that the RFID reader must be
soldered each pin carefully so that the readers will work properly, and also the RFID
The proponents tested each reader for its accuracy and found out that the readers
read the rfid tag faster and less failure. Readers cant read the rfid tag at very high speed
and can only read tags at the center of the rfid reader, since the RFID reader used in
implementing this project is low frequency. And also, there are some tags that respond
The reader 1 and reader 2 read the RFID tag faster and less failure.
Readers cant read the RFID tag at very high speed and can only read tags at the
center of the RFID reader, since the RFID tag use is low Frequency.
There are some tags that reader scan or read faster than the other tags.
Integration testing
Based on the testing, the proponents found out that the RFID reader reads the RFID
tag faster if the tag was in its reading range of the reader for about 10cm, and the ESP8266
will only work properly if the source is exactly 3.3V, so the proponents used regulator to
have the exact source.
Test Findings
In order for the RFID reader reads the RFID tag faster, the tag must be in
can use regulator or any other electronic devices as long as it provides the right
voltage source.