Sei sulla pagina 1di 1

PASAQUIAN BT 3A a.

Long column
1. Type of foundation employed when stable soil of adequate b. Spiral column
bearing capacity occurs relatively near the ground surface. c. Lally column
a. Shallow foundation 15. Piles are generally used where wooden piles would be subject
b. Deep foundation to decay or deterioration by the action of marine worms.
c. Isolated foundation a. Concrete piles
2. This type of footing may be used in place of a combined b. Friction piles
footing under the same conditions c. Pre-cast piles
a. Cantilevered footing 16. Is a system of end bearing or friction piles, pile caps, and tie
b. Trapezoidal footing beams for transferring building loads down to a suitable
c. Combined footing bearing stratum.
3. A system transfers the lateral loads on the superstructure to a. Mat foundation
the ground b. Steel Grillage foundation
a. Excavation system c. Pile foundation
b. Foundation System 17. Are spread footings supporting free-standing columns and
c. Gradation system piers.
4. the foundation bed should first be covered with a layer of a. Square footing
concrete not less than 6 in thickness and so mixed and b. Deep footing
compacted as to be nearly impervious to moisture as possible c. Isolated footing
a. Mat foundation 18. Are the continuous spread footings of foundation walls.
b. Steel Grillage foundation a. Square footing
c. Pile foundation b. Strip Footing
5. These are usually moulded in a yard or at the site allowed to c. Isolated footing
cure for 4 weeks before using.
a. Concrete piles
b. Friction piles
c. Pre-cast piles
6. Piles are constructed in the ground in the position they are to 19. What type of footing?
occupy, and are often reinforced. Practically all cast in place a. Pyramidal footing
piles are covered by patents. b. Strip Footing
a. Concrete piles c. Isolated footing
b. Cast-in-place piles
c. Pre-cast piles
7. It is to provide support for the superstructure above and
enclose a basement wall or crawl space partly or wholly
below grade.
a. Foundation walls
20. What type of footing?
b. Retaining wall
a. Pyramidal footing
c. Fence
b. Strip Footing
8. Occur when the unsupported height is more than ten times
c. Stepped footing
the shortest lateral dimension of the cross section.
a. Long column
b. Short column
c. Lally column
21. What type of footing?
9. Are fabricated steel pipes provided with flat steel plates
a. Cantilevered footing
which holds a girder or girt, and is filled with grout or concrete
b. Trapezoidal footing
to prevent corrosion?
c. Combined footing
a. Long column
22. footing is so designed so that the center of gravity of the
b. Short column
combined loads passes through the center of gravity of the
c. Lally column
footing area
10. Are short bars used to transfer the stress at the bottom of the
a. Cantilevered footing
columns to the footings?
b. Trapezoidal footing
a. Rebars
c. Combined footing
b. Caissons
c. Dowel Bars
11. Probably the most commonly used type or reinforced
concrete construction consists of a solid slab supported by
two parallel beams, the beams framing into girders, and the
girders in turn framing into columns.
23. What type of footing?
a. Two-way slab
a. Cantilevered footing
b. One way slab
b. Block/square footing
c. Three-way slab
c. Combined footing
12. May be defined as a structural member, resting on supports
usually at its ends, which supports transverse loads.
a. Beam
b. Slabs
c. Stirrups 24. Identify.
13. flat plate thickened at its column supports to increase its a. Flat slabs of plain or reinforced concrete
shear strength and moment-resisting capacity The slab is b. Beams or girders with a slab underneath
commonly reinforced with bars running in two directions c. Beams or girders with a slab on top
a. Two-way slab 25. These are concrete-filled steel pipes which are made to bear
b. One way slab on rock or hard pan.
c. Three-way slab a. Concrete piles
14. These are columns with longitudinal bars and closely spaced b. Cast-in-place piles
continuous spiral hooping c. Steel-pipe piles

Potrebbero piacerti anche