Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The potential for slip value reported applies in the instance of access by
m
m
27
able-bodied pedestrians.
High slip potential 0-24
Medium slip potential 25-35
27
The results show that under water wet conditions or other similar
m
Notes:
1. Standard cut lengths are twice the widths shown, e.g. the length of
1000mm wide Durbar is 2000mm. Please refer to Tata Steel or your
local sales representative for other dimensions.
2. The thickness of Durbar is that of the plain plate, exclusive of the
raised pattern. The studs in the pattern are typically between 1.5
and 2.2mm height.
Note:
These are typical weights; actual weights will vary owing to stud height
and positive width tolerances.
Tolerances on thickness
Thickness tolerances as per EN 10051:2010.
www.tatasteeleurope.com
Durbar is a registered trademark of Tata Steel.
Tata Steel
PO Box 10.000 While care has been taken to ensure that the information contained in this publica-
1970 CA IJmuiden tion is accurate, neither Tata Steel Europe Limited, nor its subsidiaries, accept re-
sponsibility or liability for errors or for information which is found to be misleading.
The Netherlands
E:strip.enquiries@tatasteel.com Tata Steel Europe Limited is registered in England under number 05957565 with
www.tatasteeleurope.com/strip registered office at 30 Millbank, London SW1P 4WY, United Kingdom.
Copyright 2016
IS0116:250:EN:0116 Tata Steel Europe Limited