Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
htt
Roll No. : ..
Invigilator's Signature : ..
CS/B.Tech(CHE)/SEM-7/CHE-704A/2009-10
p:/
2009
POLYMER SCIENCE & ENGINEERING
Time Allotted : 3 Hours Full Marks : 70
/q
The figures in the margin indicate full marks.
Candidates are required to give their answers in their own words as
pap
far as practicable.
GROUP A
( Multiple Choice Type Questions )
er.
c) PTFE d) PP.
ii) High product purity can be obtained by
a) bulk polymerization technique
b) solution polymerization technique
c) suspension polymerization technique
ut .
a) Surfactant b) Plasticizer
c) Solvent d) Emulsifier.
xii) Compression ratio of an injection moulding screw is the
ratio of the
a c.
77850 2
CS/B.Tech(CHE)/SEM-7/CHE-704A/2009-10
GROUP B
htt
( Short Answer Type Questions )
Answer any three of the following. 3 5 = 15
2. Define copolymers with emphasis to its types and chain
structure. 5
p:/
3. What do you mean by depolymerization ? Mention some of
the polymers which are highly prone to this. 5
4. Write down the process specifying the apparatus of how a
/q
tensile test can be carried out for a specific polymer. 5
5. Specify the manufacturing techniques of the following plastic
products : 5 1=5
pap
i) Carry bags
ii) Bottles
iii) Pipe
iv) Disposable cups
v) Injection syringe.
er.
GROUP C
wb
i) Spinning process
ii) Plastic coating
iii) Blown film extrusion technique
iv) Addition polymerization.
ut .
thermoforming process. 4
c) Characterize polypropylene and describe its application
on the basis of it. 4
in
77850 4