Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1 Introduction
1.1 Scope
These release notes summarize the operational requirements and known issues for the following
3Com Baseline Switch 2226-SFP Plus, 2250-SFP Plus and 2426-PWR Plus software release.
Software Release Filename Description
Operational Software
Baseline Switch 2226-SFP Plus
z 3CBLSF26
bfs01_01_00_15.bin Baseline Switch 2250-SFP Plus
z 3CBLSF50
Baseline Switch 2426-PWR Plus
z 3CBLSF26PWR
4 Bug fixed
4.1 Bug fixed for Release v01.01.00.14
z Fixed intermittent erroneous PoE overload reports resulting in PoE being disabled unnecessarily..
z Fixed recovery of PoE on port after overload condition is removed.
5 Upgrading Software
For instructions on how to upgrade the Switch to this firmware version, please refer to the 3Com
Baseline Switch 2226-SFP Plus, 2250-SFP Plus and 2426-PWR Plus User Guide (part number
10016622 Rev BA). We recommend backing up the configuration parameters before starting the
upgrade process.
Please note it is only necessary to upgrade the Switch to this version of code if you have a Switch
that was supplied with a previous version of the software. If you are unsure of the version of software
in your switch, refer to the User Guide for instructions on how to determine the Software version.
z Always assign system critical PoE devices to high priority ports. By default the lowest number
ports have priority over higher numbered ones (i.e. port 1 has the highest priority, port 24 the
lowest)
z Set the guaranteed power to whatever is required for the connected devices
z Monitor the total system power during installation of new PoE devices, and if the total power
being drawn reaches or comes close to about the 154W limit consider installing additional PoE
capability