Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Assignment 1
1. Two parallel shafts about 600 mm apart are to be connected by spur gears. One shaft is to run
at 360 rpm and the other at 120 rpm. Design the gear, if circular pitch is to be 25 mm.
2. A gear box has an input speed of 2000 rpm clockwise and an output speed of 500 rpm
anticlockwise. The input power is 50 kW and the efficiency is 60%. Determine the following:
3. A simple gear train has two spur gears. The input gear has 20 teeth and the output gear has
100 teeth. The input rotates at 2000 rpm clockwise.
i. Calculate the gear ratio and the output speed (5; 400 rpm clockwise)
ii. The input torque is 15 Nm and the efficiency is 65%. Calculate the output power
and the holding torque. (2042 W; 33.75 Nm clockwise)
4. Calculate the gear ratio for compound chain shown in figure below. If the input gear rotates
clockwise, in which direction does the output rotates?
GEAR TEETH
A 20
B 100
C 40
D 100
E 10
F 100
1. A prime pulley running at 300rpm drives a D.C generator at 500rpm by a belt drive.
Given that a diameter of the prime pulley is 60cm. Assuming slip of 3 percent,
determine the diameter of generator of pulley, if the belt thickness is 6mm.
[Answer: 0.346m]
[Answer: 0.447m]
3. The diameter of a pulley on the driving shaft rotating at 120 rpm is 60 cm. Another
shaft is to be driven at 300 rpm by an open belt drive, = 0.3 and the distance
between the centre line of the shaft is 2.4 m. Determine the tension on the tight and
slack side of the belt to transmit 3 kW power.
4. Explain in detail three (3) types of belt that used in real engineering applications.