Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Issue 08/2007
EKSMAL
Ready-mix grout, compensating shrinkage due to setting
Product based on cement, high-quality fillers and admixtures
Substrate preparation:
Increase in compressive strength after 24 hours The substrate should be clean, cleaned of grease and
depending on temperature well wetted with water. In case of porous substrates it is
recommended to perform preparation with a precoat
Compression strength
60
prepared with Bond-U.
50
40
(MPa)
30 Placement:
20
10 The product is mixed with the required quantity of water,
0 as given below in the Table, up to the required
0 5 10 15 20 25 30 35 consistency, with slow mixing. The grout mixture is
Temperature (C) allowed to lie for 2-3 minutes and is mixed again, and
then is placed by pouring.
During the first few hours the placed material is
protected against high temperatures >25oC, direct
Increase in compressive strength in course exposure to sun, and draught and is "cured" with water.
of time (at t=20C)
Type of Eksmal W/M ratio
Compression strength
80
70 Eksmal-1 0,130-0,145
60
50
Eksmal-4 0,120-0,135
(MPa)
40 Eksmal-8 0,090-0,110
30
20
Eksmal-16 0,080-0,100
10 Eksmal-32 0,065-0,085
0
0 1 7 14 21 28 M - material for grouting
Age (days)
1 EKSMAL 1/2
Type of product: Cleaning:
The product is manufactured in several types, Tools and equipment are cleaned with water
depending on the particle-size distribution i.e. on the immediately after their use.
maximum aggregate particle:
Consumption:
Storage:
From 2,2 to 2,4 kg/dm3, depending on the Eksmal
employed. The quantity of needed material is In original closed packing. In dry premises. Shelf life 12
estimated according to the volume that has to be months.
grouted.
Health hazard:
It is necessary to avoid contact of the product with skin (use protective gloves). The material is not toxical, however, in case of accidental contact, in case
when areas of the skin have been contaminated, those spots should immediately be washed with water and soap. If the material has been splashed into
eyes, they should immediately be rinsed with a lot of water and medical assistance should be asked for.
Fire:
Eksmal is a non-flammable.
Cleaning and discarding:
Loose residues of Eksmal are cleaned with water. The old and used packing should be discarded in accordance with the local relevant regulations for
that kind of waste.
2/2 EKSMAL 2