Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Shilpi Gupta
Dept. of Electrical Engineering
IIT Kanpur
Mar 9, 2017
1
Comparator: Opamp under open Loop condition
VO
VCC
VS2 -VS1
-VCC
2
~ -12V
~ +12V
3
Comparator
4
Schmitt Trigger
5
Schmitt Trigger
6
Integrator
7
Differentiator
8
Log Amplifier
9
Temperature Sensor ?
10
D
+VCC
VS
R1 VO1
-VCC
11
D
+VCC
VS
R1 VO1
-VCC
13
Multiplier
14
Experiment 7
(Mar 20-22 [Mon, Tue, Wed sections], Mar 31 [Fri sections])
Do theoretical Av and
experimental Av
match?
Non-inverting Amplifier
Wire the circuit of Fig. 7. Choose R2 = 51 k . Adjust
the FG output to produce Vi = 0.1 sin( t) (f = 1 kHz).
Observe and sketch Vi and V0 waveforms.
Measure the voltage gain.
Do theoretical Av and
experimental Av
match?
Difference Amplifier
Difference Amplifier
R2 R4 R R2
V0 Vi1 Vi 2 1
R1 R4 R R3 R1
Difference Amplifier
Choose R such that
Common Mode Gain
R2
51 k
R1
10 k
2
6
R
V0
+ 3
R3
Vi 10 k R4
47 k
R
10 k
Fig.8
Vi to both R1 and R3. Adjust the FG
output to produce Vi = 10 sin( t) (f = 1
kHz).
Observe the output voltage V0 on the
DSO and minimize its amplitude by
adjusting the 10 k potentiometer.
Perform this step as best as you can. As
V0 decreases with the potentiometer
adjustment, increase the sensitivity of
the DSO channel and obtain the very
minimum possible V0.
Keep this setting of the potentiometer
unchanged for the next part of the
experiment.
Calculate Ac (V0/Vi) common-mode
Choose R such
that Acm is
minimum