Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2.In a semiconductor diode, P-side is grounded and N-side is applied a potential of -5V through a resistance of
100 ohms. the diode shall
(a) conduct fully (b) not conduct
(c) conduct partially (d) none of these
rld
4. when current through a zener diode increases by a factor of 2, voltage across its terminals
(a) is halved (b) is doubled too
(c) is practically unchanged (d) none of these
9.the output voltage at no load in an unregulated power supply is the same as its output voltage at rated load
current. its internal resistance is therefore
JN
10. mark the rectifier circuit that produces the least ripple
(a) single rectifier,half wave, single phase (b) four rectifiers,full wave,single phase
(c) two rectifiers,full wave,single phase (d) six rectifiers,full wave,three phase.
14. a given opamp has an open loop gain of 110dB and a CMRR rating of 106dB. what should be the open loop
common mode gain of this op-amp?
(a) it cannot be determined from the given data (b)4dB
rld
(c) 216 dB (d) 110Db
15. in a 555 astable multivibrator operating from Vcc of 15V, the output wave from duty cycle is 0.4 (duty cycle
= ON-time/total time period.) the circuit is slightly modified with the capacitor now charging from a voltage of
30V rather than Vcc. the duty cycle of the output waveform in the modified circuit will
(a) remain unchanged (b) become about 0.6
(c) be approximately 0.2 (d) none of these
17. in the astable mode of operation of IC 555, the timing capacitor always charges between
(a) 0 and 1/3 Vcc (b) 1/3 Vcc and 2/3Vcc
(c) 0 and 2/3 Vcc (d) 0 and Vcc
19.A NOR gate is equivalent to a bubbled AND gate. this statement is an outcome of
(a) demorgans theorems (b) involution law
(c) absorption law (d) idempotent law
20.for one of the following conditions, clocked j-k flip flop can be used as DIVIDE BY 2 circuit where the pulse
JN
21. in a presettable, clearable positive edge triggered J-K flip flop, the Q output when the flip flop is clocked for
J=1,K=0,preset=1 and clear = 0 will be
(a) 1 (b) 0
(c) indeterminate (d) complement of what it was at the time of clocking
(assume all the inputs to be active LOW inputs).
22. A 4-bit circulating register is initially set to 0001(1 is the true output of the first flip flop and represents LSB).
4-bit number preset in the register at the end of 16 clock pulses is
(a) 0001 (b) 0010
(c) 0100 (d) 1000
23. a shift counter comprising of 5 flip flops with an inverse feedback from the output of the MSB flip flop to the
input of the LSB flip flop is a
(a) divide by 32 counter (b) divide by 10 counter
(c) 5-bit shift register (d) modulus-5 counter
rld
25. the average conversion time in a 4-bit counter type A/D converter run by a 10 MHZ clock shall be
(a) 8ms (b) 400ns
(b) 800ns (d) none of these
27. if the received carrier frequency in an AM communications broadcast receiver is changed from 560kHz to
1120kHz the resonant frequency of the IF tuned circuits
(a) would have to be changed from 455Khz to 910kHz.
(b) would remain unchanged at 455kHz
(c) would also change in the same proportion but in the opposite direction.
33. an antenna is radiating 100 watts and is drawing 2A from the transmitter, its radiation resistance is :
(a) 100 W (b) 50 W
(c) 25 W (d) none of these
34.smaller the beamwidth angle :
(a) smaller the directivity (b) higher the directivity
(c) higher the power gain (d) none of these
rld
(a) maximum reception is along the axis
(b) maximum reception is perpendicular to the axis
(c) directional pattern is bi-directional
(d) none of these
41. a transmission line is having a reflection coefficient of 1/3 when terminated in a certain load. it is SWR is :
(a) 2 (b)
(c) 3 (d) none of these
JN
47. if the heights of the transmitting and receiving antennas are doubled, the range of TV broadcast:
rld
(a) decrease by a factor of 2 (b) increases by a factor of 2
(c) increases by factor of 1:414 (d) is reduced to one-fourth.
50. a transmission line has an SWR of 3 when terminated in a certain load. the reflection co-efficient is
(a) 3 (b)
(c) 1/3 (d) none of these
52. electromagnetic wave in which the electric field is entirely transverse to the direction of propogation is known as
(a) TE wave (b) TEM wave
(c) TM wave (d) TE10 wave
(e) TE11 wave
53. one of the following modes does not exist in wave guides
JN
55. for a rectangular wave guide with a=2 cm and b=1 cm, the cut-off wavelength for TE10 mode will be
(a) 2 cm (b) 1 cm
(c) 4 cm (d) none of these.
56. in a radar system, a rotating system is used to
(a) determine the target range (b) determine the target cross-section
(c) determine the target bearing (d) none of these
58. a radar system that can determine the range of the target along with the target velocity is
(a) CW radar (b) MTI
(c) pulse radar (d) Doppler radar
rld
59. market the correct expression
(a) Doppler shift = 2vrf/c (b) Doppler shift = 2cf/v4
(c) Doppler shift = 2f/cv4 (d) Doppler shift = vrf/c
68. stability of a control system can be determined from one of the following responses.
(a) impulse response (b) step response
(c) ramp response (d) steady state response
P (s) = (s+1)(s+3)/s(s+2)(s+4)
its a
(a) type-5 system (b) type -2 system (c) type-3 system (d) type-4 system
rld
70. gain margin can be determined from the root locus plot by
(a) value of gain factor (K) at imaginary crossover/design value of (k)
(b) design value of gain factor (k) / value of gain factor (k) at imaginary crossover
(c) value of gain factor (K) at real axis crossover/design value of (k)
(d) none of these
71. a higher value of gain factor (K) at the imaginary axis crossover of the root locus part of a control system
Wo
(a) brings it closer to instability (b) takes it farther from instability
(c) is always undesirable (d) none of these
72. for drawing the root locus plot of a certain closed loop control system, one needs to know
(a) only the open loop transfer function of the system
(b) the closed loop transfer function
(c) the closed loop system pole-zero map
(d) the open loop transfer function, gain and phase margins
73. when the PLL is being used as a frequency multiplier or a frequency divider, the output is taken from
TU
(a) the VCO input (b) the output of phase comparator
(c) the VCO output (d) LPF output
75. while connecting SCRs in series, the individual SCRs chosen for the purpose should have closely matched
(a) di/dt rating (b) reverse biased characteristics
(c) forward and reverse blocking characteristics (d) forward ON-state characteristics
76. while connecting SCRs in parallel, the SCRs to be connected in parallel should have closely matched
(a) forward ON- state characteristics
(b) forward and reverse OFF- state characteristics
(c) forward OFF-state and ON-state characteristics
(d) SCRs cannot be connected in parallel
77. a UJT relaxation oscillator circuit produces a sawtooth like waveform
(a) at B1 terminal (b) at B2 terminal
(c) across the capacitor (d) none of these
78. in half wave SCR power control circuit, if the firing angle is 300 c, then for one complete cycle of operation,the
load gets power for
(a) 600 (b) 1500 (c) 3300 (d) 300
rld
(c) astable multivibrator (d) Schmitt trigger
81. one of the following can be used to generate a pulse when ever triggered:
(a) flip-flop (b) monostable multivibrator
(c) astable multivibrator (d) Schmitt trigger
87. the characteristic impedance of a certain transmission line section is 75 ohms. if the length of the line is
doubled, the characteristic impedance would
(a) reduce to half (b) double too
(c) increase four times (d) characteristic impedance is independent of length of line.
90. in the radar guidance of missiles where the missile has its own radar and it extracts the tracking data from the
target reflected energy, the technique is known as
(a) command guidance (b) beam rider guidance
(c)homming guidance (d) none of these
rld
Wo
TU
JN
ANSWERS FOR THE ABOVE
1.C
2.A
3.A
4.C
5.B
6.B
7.C
8.D
9.B
10.D
11.D
rld
12.B
13.B
14.B
15.C
16.B
17.B
18.B
19.A
20.A
21.B
22.A
23.B
24.A
Wo
25.C
26.B
27.B
28.B
TU
29.C
30.C
31.A
32.C
33.C
34.B
35.A
JN
36.A
37.A
38.B
39.A
40.D
41.A
42.B
43.C
44.A
45.A
46.D
47.C
48.A
49.A
50.B
51.B
52.A
53.C
54.A
55.C
56.C
57.B
58.B
59.A
60.B
61.C
rld
62.B
63.C
64.C
65.A
66.B
67.C
68.A
69.B
70.A
71.B
72.A
73.C
74.B
Wo
75.C
76.A
77.C
TU
78.B
79.C
80.B
81.B
82.A
83.A
84.D
85.B
JN
86.A
87.D
88.C
89.A
90.C