Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
PSOP-8
1
Preliminary Datasheet
Pin Configuration
MP Package
(PSOP-8)
PG 1 8 GND
EN 2 7 ADJ
VIN 3 6 VOUT
VCTRL 4 5 NC
Pin Description
Pin Pin
Function
Number Name
1 PG Assert high once VOUT reaches 92% of its rating voltage
2 EN Enable input
3 VIN Input voltage
4 VCTRL Input voltage for controlling circuit
5 NC Not connected
6 VOUT Regulated output voltage
Adjust output: when connected to ground, the output voltage is set by
7 ADJ internal resistors; when external feedback resistors are connected, the
output voltage will be VOUT=0.8(R1+R2)/R2
8 GND Ground
2
Preliminary Datasheet
3
Preliminary Datasheet
Ordering Information
AP2132B -
BCD Semiconductor's Pb-free products, as designated with "G1" suffix in the part number, are RoHS compliant
and Green.
4
Preliminary Datasheet
Note 1: Stresses greater than those listed under Absolute Maximum Ratings may cause permanent damage to
the device. These are stress ratings only and functional operation of the device at these or any other conditions
beyond those indicated under Recommended Operating Conditions is not implied. Exposure to Absolute
Maximum Ratings for extended periods may affect device reliability.
5
Preliminary Datasheet
Electrical Characteristics
VIN = VOUT +0.5V, VCTRL= VEN =5V, TA=25oC, CIN=COUT=10F, CCTRL=1F, IOUT=10mA, Bold typeface
applies -40 oCTA85 oC unless otherwise specified.
VOUT + 0.5VVIN5V ,
Line Regulation VRLINE 2 mV
IOUT = 10mA
IOUT =500mA 80 120 mV
Thermal Shutdown o
20 C
Hysteresis
VOUT Power
VTHPG 92 %
Good Voltage
VPG Hysteresis 7 %
Adjust Pin
200 mV
Threshold
Thermal Resistance
JC PSOP-8 40 C/W
(Junction to Case)
6
Preliminary Datasheet
0.40 0.40
AP2132B-1.2V AP2132B-1.2V
0.38 0.38
VIN=2.2V VIN=VOUT+1V
0.36 VCTRL=VEN=5V 0.36 VCTRL=VEN=5V
0.34 0.34 No Load
Supply Current (mA)
0.30 0.30
0.28 0.28
0.26 0.26
o
TC=-40 C
0.24 0.24
o
TC=25 C
0.22 0.22
o
TC=85 C
0.20 0.20
0.0 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 -25 0 25 50 75 100 125
o
Output Current (A) Case Temperature ( C)
Figure 4. Supply Current vs. Output Current Figure 5. Supply Current vs. Case Temperature
1.5
0.50
1.4 Enable High Voltage
0.45 AP2132B-1.2V
1.3 Enable Low Voltage
No Load
1.2
0.40 VCTRL=VEN=5V
Enable High/Low Voltage (V)
1.1
1.0 0.35
Supply Current (mA)
0.9
0.30
0.8
0.7 0.25
0.6 0.20
0.5
o
0.4 AP2132B-1.2V 0.15 TC=-40 C
VCTRL=5V o
0.3 0.10 TC=25 C
VIN=2.2V
0.2 o
0.05
TC=85 C
0.1
0.0 0.00
-25 0 25 50 75 100 125 0.0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0 5.5 6.0
o
Case Temperature ( C) Input Voltage (V)
Figure 6. Enable High/Low Voltage vs. Case Temperature Figure 7. Supply Current vs. Input Voltage
7
Preliminary Datasheet
1.30 1.5
AP2132B-1.2V 1.4
1.28
VIN=2.2V 1.3
1.26 VCTRL=VEN=5V 1.2
1.1
1.24
1.0
Output Voltage (V)
Figure 8. Output Voltage vs. Case Temperature Figure 9. Output Voltage vs. Output Current
400
1.50
360
AP2132B-1.2V
1.35 VCTRL=VEN=5V
320
1.20
280
Dropout Voltage (mV)
1.05
Output Voltage (V)
240
0.90
AP2132B-1.2V
200
0.75 VCTRL=VEN=5V
No Load 160
0.60
o
TC=-40 C 120
0.45
o
TC=25 C TC=-40oC
0.30 80
TC=25oC
o
TC=85 C
0.15 40
TC=85oC
0.00 0
0.0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0 5.5 6.0 0.0 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0
Input Voltage (V) Output Current (A)
Figure 10. Output Voltage vs. Input Voltage Figure 11. Dropout Voltage vs. Output Current
8
Preliminary Datasheet
400
280 VCTRL=VEN=5V
240
40 40
0 0
-25 0 25 50 75 -30 -15 0 15 30 45 60 75 90 105 120
o
Case Temperature ( C) o
Case Temperature ( C)
Figure 12. Dropout Voltage vs. Case Temperature Figure 13. Short Current vs. Case Temperature
100
AP2132B-1.2V
90 VOUT=1.2V
80 CIN=10F, COUT=10F, CCTRL=1F
VCTRL=VEN=5V, VIN=2.2V to 3.2V, IOUT=10mA
70
60
PSRR (dB)
50
40
30
20
10
0
10 100 1k 10k 100k
Frequency (Hz)
Figure 14. PSRR vs. Frequency Figure 15. VIN Start up Waveform
(VCTRL=VEN=5V, VIN=0 to 2.2V, No Load)
9
Preliminary Datasheet
VPG
1V/div
VOUT
1V/div
VCTRL
1V/div
IIN
1A/div
Time 80 s/div
Figure 16. VEN Start up Waveform Figure 17. VCTRL Start up and Shut down Waveform
(VCTRL =5V, VEN =0 to 5V, VIN=2.2V, No Load) (VCTRL =0 to 5V, VEN =5V, VIN=2.2V, No Load)
10
Preliminary Datasheet
Typical Application
10k
VCTRL VCTRL PG VIN
EN
VIN VIN
GND
VOUT VOUT
R1 ADJ
CCTRL C1 C2
1 F 10 F 10 F
R2
0.8 (R1+R2)
VOUT =
R2
11
Preliminary Datasheet
Mechanical Dimensions
12
BCD Semiconductor Manufacturing Limited
http://www.bcdsemi.com
IMPORTANT NOTICE
IMPORTANT NOTICE
BCD Semiconductor
BCD Semiconductor Manufacturing
Manufacturing Limited
Limited reserves
reserves the
the right
right to
to make
make changes
changes without
without further
further notice
notice to
to any
any products
products oror specifi-
specifi-
cations herein.
cations herein. BCD
BCD Semiconductor
Semiconductor Manufacturing
Manufacturing Limited
Limited does
does not
not assume
assume any
any responsibility
responsibility for
for use
use of
of any
any its
its products
products for
for any
any
particular purpose,
particular purpose, nor
nor does
does BCD
BCD Semiconductor
Semiconductor Manufacturing
Manufacturing Limited
Limited assume
assume any
any liability
liability arising
arising out
out of
of the
the application
application or
or use
use
of any
of any its
its products
products or
or circuits.
circuits. BCD
BCD Semiconductor
Semiconductor Manufacturing
Manufacturing Limited
Limited does
does not
not convey
convey anyany license
license under
under its
its patent
patent rights
rights or
or
other rights
other rights nor
nor the
the rights
rights of
of others.
others.
MAIN SITE
MAIN SITE
- Headquarters
BCD Semiconductor Manufacturing Limited - Wafer
BCD FabSemiconductor Manufacturing Limited
BCD Semiconductor
- Wafer Fab Manufacturing Limited Shanghai SIM-BCD
- IC Design GroupSemiconductor Manufacturing Co., Ltd.
No. 1600, Zi
Shanghai Xing Road,
SIM-BCD Shanghai ZiZhu
Semiconductor Science-basedLimited
Manufacturing Industrial Park, 200241, China 800 Yi Shan Road,
Advanced Shanghai
Analog 200233,
Circuits China Corporation
(Shanghai)
Tel:
800,+86-21-24162266, Fax: +86-21-24162277
Yi Shan Road, Shanghai 200233, China Tel: +86-21-6485 1491,YiFax:
8F, Zone B, 900, Shan+86-21-5450 0008200233, China
Road, Shanghai
Tel: +86-21-6485 1491, Fax: +86-21-5450 0008 Tel: +86-21-6495 9539, Fax: +86-21-6485 9673
REGIONAL SALES OFFICE
Shenzhen OfficeSALES OFFICE
REGIONAL Taiwan Office USA Office
Shanghai
Shenzhen SIM-BCD
Office Semiconductor Manufacturing Co., Ltd., Shenzhen Office BCD Taiwan
Semiconductor
Office (Taiwan) Company Limited BCD Office
USA Semiconductor Corp.
Unit A Room
Shanghai 1203, Skyworth
SIM-BCD Bldg., Gaoxin
Semiconductor Ave.1.S., Nanshan
Manufacturing Co., Ltd.District,
Shenzhen Shenzhen,
Office 4F, 298-1,
BCDRui Guang Road,(Taiwan)
Semiconductor Nei-Hu District,
Company Taipei,
Limited 30920Semiconductor
BCD Huntwood Ave.Corporation
Hayward,
China
Advanced Analog Circuits (Shanghai) Corporation Shenzhen Office Taiwan4F, 298-1, Rui Guang Road, Nei-Hu District, Taipei, CA 94544,
30920 USA Ave. Hayward,
Huntwood
Tel:
Room +86-755-8826
E, 5F, Noble 7951 Tel: +886-2-2656
Center, No.1006, 3rd Fuzhong Road, Futian District, Shenzhen 518026, China Taiwan 2808 Tel :94544,
CA +1-510-324-2988
U.S.A
Fax: +86-755-88267951
Tel: +86-755-8826 7865 Fax: +886-2-2656 28062808
Tel: +886-2-2656 Fax:: +1-510-324-2988
Tel +1-510-324-2788
Fax: +86-755-8826 7865 Fax: +886-2-2656 2806 Fax: +1-510-324-2788