Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
This standard has been approved for use by agencies of the Department of Defense.
Copyright ASTM, 100 Barr Harbor Drive, West Conshohocken, PA 19428-2959, United States.
1
COPYRIGHT 2000 American Society for Testing and Materials
Information Handling Services, 2000
A 167
TABLE 1 Chemical RequirementsA
Composition, %
UNS Type Car- Man- Phos- Sulfur Silicon Chromium Nickel Molyb- Other Elements
Desig- bon ganese pho- denum
nationB rus
S30215 302B 0.15 2.00 0.045 0.030 2.003.00 17.019.0 8.0010.0 ... N 0.10
S30800 308 0.08 2.00 0.045 0.030 0.75 19.021.0 10.012.0 ... ...
S30900 309 0.20 2.00 0.045 0.030 0.75 22.024.0 12.015.0 ... ...
S31000 310 0.25 2.00 0.045 0.030 1.50 24.026.0 19.022.0 ... ...
A
Maximum unless range or minimum is indicated.
B
New designation established in accordance with Practice E 527 and SAE J 1086.
UNS Tensile Strength, min Yield Strength, minB Elongation Hardness, maxC
DesignationA in 2 in. or
Type
ksi MPa ksi MPa 50 mm, Brinell Rockwell B
min, %
S30215 302B 75 515 30 205 40.0 217 95
S30800 308 75 515 30 205 40.0 183 88
S30900 309 75 515 30 205 40.0 217 95
S31000 310 75 515 30 205 40.0 217 95
A
New designation established in accordance with Practice E 527 and SAE J 1086.
B
Yield strength shall be determined by the offset method at 0.2 % in accordance with Test Methods and Definitions A 370. Unless otherwise specified, an alternative
method of determining yield strength may be based on a total extension under load of 0.5 %.
C
Either Brinell or Rockwell B hardness is permissible.
The American Society for Testing and Materials takes no position respecting the validity of any patent rights asserted in connection
with any item mentioned in this standard. Users of this standard are expressly advised that determination of the validity of any such
patent rights, and the risk of infringement of such rights, are entirely their own responsibility.
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM Headquarters. Your comments will receive careful consideration at a meeting of the responsible
technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should make your
views known to the ASTM Committee on Standards, 100 Barr Harbor Drive, West Conshohocken, PA 19428.
This standard is copyrighted by ASTM, 100 Barr Harbor Drive, West Conshohocken, PA 19428-2959, United States. Individual
reprints (single or multiple copies) of this standard may be obtained by contacting ASTM at the above address or at 610-832-9585
(phone), 610-832-9555 (fax), or service@astm.org (e-mail); or through the ASTM website (http://www.astm.org).
2
COPYRIGHT 2000 American Society for Testing and Materials
Information Handling Services, 2000