Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
NET
MANUAL
PRODIVE@ABV.BG MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
3. Connect the Cable with a free USB Port. (The Dive Computer is
not connected in this moment.)
4. Check in Device Manager if the driver is detected, note of which
port is (in my case COM 5).
WWW.PRODIVESYSTEM.NET
MANUAL
PRODIVE@ABV.BG MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
PRODIVE@ABV.BG MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
PRODIVE@ABV.BG MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
9. Connect the cable with the Dive computer. Carefully clean the
PC interface pins and the water sensor contacts of your Dive
computer with a soft eraser or dry cloth. Secure the clip, making
sure, that it is securely attached.
WWW.PRODIVESYSTEM.NET
MANUAL
PRODIVE@ABV.BG MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
10. Tab (OK) to datatransfer from your dive computer to your PC.
Make sure, that the Dive computer is connected before you start.
WWW.PRODIVESYSTEM.NET
MANUAL
PRODIVE@ABV.BG MANUAL
WWW.PRODIVESYSTEM.NET
MANUAL
USB DIY data cable for Suunto dive computers Zoop, D3,
Mosquito, HelO2, Vyper, Vytec
USB cable works with the following programs
2. Subsurface 4.2
3. dive PAL
4. Diving Log 5.0
Video Instruction manual
www.youtube.com/watch?v=0_eCkR_AaFg
Publisher
Pro Dive System
10, Ivan Hadjihristov str.
6006 Stara Zagora, Bulgaria
Copyright
All images and text in this instruction manual, as well as the instruction manual itself are
copyright protected, any further use must be approved in writing by
www.prodivesystem.net
Disclaimer
The USB Cable, was tested prior to the delivery. Connection, use and operation shall be
at your own risk. No liability shall be assumed for damage or loss of data or lack of
waterproofness.
WWW.PRODIVESYSTEM.NET
MANUAL
PRODIVE@ABV.BG MANUAL