Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SPECIFICATION FOR
MARBLE
SECTION 04400
SECTION 04400
MARBLE
INDEX
Item No.
PART 1
Title
Page No.
GENERAL
1.01
Description
1.02
Submittals
1.03
1.04
Project Requirements
PRODUCTS
Materials
EXECUTION
3.01
Installation
3.02
Cleaning
Last Page
PART 2
2.01
PART 3
04400 - 1
SECTION 04400
MARBLE
PART 1 - GENERAL
1.01
DESCRIPTION
This section covers the furnishing and installation of marble tile for cabinet tops and
ablution area seating as shown on drawings. The Contractor shall furnish all labor,
material, tools and equipment required to complete the work.
1.02
SUBMITTALS
A. Shop Drawings:
Shop drawings shall be submitted in accordance with Submittals section, showing the
details of jointing and setting.
B. Samples:
Duplicate sets of samples of marble shall be submitted to the Royal Commission for
approval. Such samples shall be included which show the full range of color and
texture.
1.03
PROJECT REQUIREMENTS:
A. Environmental Condition:
Material shall not be set when the air temperature of the material
is below 5 deg C.
04400 - 1
PART 2 - PRODUCTS
2.01
MATERIALS
A. General:
Marble shall be within the range of extremes in color and markings
permitted by the approved samples. Terms relating to marble shall
be as defined in ASTM C119.
1.
2.
3.
Abrasive Hardness:
ASTM C241.
Marble for specific
applications as designated on the drawings, shall have an
abrasive hardness of not less than 12.
4.
B. Material:
Marble units shall be minimum 20mm thick of the designs indicated on the drawings,
and as approved by the Royal Commission.
PART 3 - EXECUTION:
3.01
INSTALLATION:
A. Setting:
Marble units shall be set in a dry concrete setting bed and tamped until fully bedded to
the proper level. The units shall then be removed and back purged with wet cement
before final setting.
04400 - 2
B. Protection:
Marble units shall not be disturbed until mortar and grout have set.
3.02
CLEANING
On completion, clean exposed marble. Remove foreign material, excess mortar, and
stains. Cleaning solution shall be of the type recommended by the marble producer.
The use of sandblasting, steel wire brushes, and acid methods of cleaning shall not be
allowed.
- End of Section -
04400 - 3