Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
DOC
SALLOX C200 NF
PRE-MIXED TIN SULPHATE AND ADDITIVE SOLUTION FOR
ELECTROCOLOURING
PRODUCT DESCRIPTION
A pre-mixed tin sulphate and additive solution developed to facilitate improved management of the
tin electrocolouring process.
ADVANTAGES
The pre-mixed solution contains the correct ratio of tin sulphate and additive thus allowing
accurate adjustments and greater stability of the bath solution.
SALLOX C200 NF avoids the problem of tin powder dissolution.
Easy handling and storage.
Direct addition of SALLOX C200 NF allows the adjustment of both tin and the additive to be
achieved.
OPTIMUM OPERATING CONDITIONS
SALLOX C 200 NF
Sulphuric acid
Temperature
72 - 120 g/l
20 g/l
22 C
96 g/l
CONSUMPTION
Allowing an average drag out the consumption of SALLOX C200 NF will be approximately 30
grams for each square meter of aluminium processed.
SOLUTION PREPARATION AND INSTALLATION
Thoroughly clean and rinse both the tank and electrodes;
Partially fill the tank (approximately 30%) with demineralized water;
Add:
- first 16 g/l of sulphuric acid
- then 25 g/l of SALMIX NF40
- then 96 g/l of SALLOX C200 NF
Mix thoroughly to ensure a good homogeneous solution is achieved;
Top up tank to operating level with demineralised water and mix (stirring) thoroughly;
Ensure solution temperature is within the range 20 to 25 C;
Analyse the solution to ensure the operating concentration range has been achieved. The solution
is now ready for use.
1/3
Note: The use of SALMIX NF40 is necessary for the make-up of new solutions. During the
normal use small additions of SALMIX NF40 may be required.
METHOD
CALCULATION
A
STORAGE
SALLOX C200 NF container should be kept tightly closed and it is good management practice to
store all chemicals in a locked weatherproof area to control access of unauthorised persons and to
provide protection from the elements.
For further information on SALLOX C200 NF or any other of the wide range of products we have
developed for use in the aluminium finishing industry please contact the Marketing or Technical
Dept of ITALTECNO S.R.L.
This information is intended only for the individual or entity to whom this document is sent. Any
unauthorized copying, disclosure or distribution of the material in this document are strictly
forbidden.
3/3