Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The company uses multiple Layer 3 protocols and requires authentication for security. Which
protocol should be used for this remote access?
LMI
PPP
HDLC
Frame Relay
Refer to the exhibit. The network administrator is configuring R1 to connect to R2, which is a
non-Cisco router. Which encapsulation method will need to be configured for communication
to occur?
HDLC
HSSI
ISDN
IPCP
PPP
3 When customers use credit cards to make purchases at a small business, a modem is heard
dialing a telephone number to transfer the transaction data to the central office. What type of
WAN serial connection is in use?
leased line
point-to-point
circuit switched
packet switched
4 What is the data transmission rate for the DS0 standard?
44 kb/s
64 kb/s
1.544 Mb/s
44.736 Mb/s
6 What does a Frame Relay switch use to inform the sender that there is congestion?
FECN
BECN
DE
FCS
7 At what physical location does the responsibility for a WAN connection change from the
user to the service provider?
demilitarized zone (DMZ)
demarcation point
local loop
cloud
8 Which field of a frame uses error detection mechanisms to verify that the frame is not
damaged in transit?
FCS
MTU
flag
control
protocol
9 Which two statements describe the function of time-division multiplexing? (Choose two.)
Multiple data streams share one common channel.
Conversations that require extra bandwidth receive any unused time slices.
Time slots are utilized on a first-come, first-served basis.
Time slots go unused if a sender has nothing to transmit.
Priority can be dedicated to one data source.
10
Refer to the exhibit. What statement is true about the exhibited output?
LCP is in the process of negotiating a link.
LCP and NCP are waiting for CHAP authentication to complete.
LCP negotiation has completed successfully, but NCP negotiation is in progress.
LCP and NCP negotiation is complete, and the data link service is available to carry packets.
11 What occurs in the encapsulation process as a data packet moves from a LAN across a
WAN?
The Layer 2 encapsulation changes to a format that is appropriate for the WAN
technology.
The Layer 3 encapsulation changes to a format that is appropriate for the WAN
technology.
Both Layer 2 and Layer 3 encapsulation change to a technology that is appropriate for
the WAN.
Both Layer 2 and Layer 3 encapsulation remain constant as the data packet travels
throughout the network.
13 In which two layers of the OSI model are key differences found between a LAN and a
WAN. (Choose two.)
Layer 1
Layer 2
Layer 3
Layer 4
Layer 6
Layer 7
15
Refer to the exhibit. A network administrator has a connectivity problem between the serial
interfaces of Merida and Vargas. What is the cause of the problem?
Authentication is required on the serial link.
The encapsulation is misconfigured.
The IP addresses are on different subnets.
The serial interface on Vargas is shutdown.
The loopback interfaces on both routers are not configured.
What best describes the use of a data-link connection identifier (DLCI)?
an address identifying a virtual circuit
a logical address identifying the DCE device
an address identifying a Layer 3 service across a Frame Relay network
a logical address identifying the physical interface between a router and a Frame Relay switch
17
Refer to the exhibit. What statement is true about the debug output?
R2 is using PAP instead of CHAP.
The routers have different CHAP passwords configured.
The administrator performed a shutdown on the R2 PPP interface during negotiation.
The Layer 3 protocol negotiation caused the connection failure.
18 What two services allow the router to dynamically map data link layer addresses to network
layer addresses in a Frame Relay network? (Choose two.)
ARP
ICMP
Proxy ARP
Inverse ARP
LMI status messages
21 Which three statements describe functions of the Point-to-Point Protocol with regards to the
OSI model? (Choose three.)
operates at all layers of the OSI model
provides a mechanism to multiplex several network layer protocols
can be configured on both synchronous and asynchronous serial interfaces
uses Layer 3 of the OSI model to establish and maintain a session between devices
uses the data link layer to configure such options as error detection and compression
uses network control protocols to test and maintain connectivity between devices
22 Which statement is true about the Cisco implementation of the HDLC protocol?
It supports authentication.
It has a universally compatible frame format.
It is the default encapsulation for serial interfaces on Cisco routers.
It does not support multiple protocols across a single link.
23 Permanent virtual circuits and switched virtual circuits are both part of which option for WAN
connectivity?
leased line
cell switching
packet switching
circuit switching