Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Measured results of
Line Code
Experiment Objectives:
1.
2.
3.
4.
5.
Experiment theory:
For digital transmission system, the advantages of the applications of line codes are as
follow:
Self-synchronization:
Line code signal has the advantage of sufficient timing information, which can make the bit
synchronizer catches the timing or pulses signal accurately to achieve self-synchronization.
Low bit error rate:
Digital signal can be recovered by comparator, which can reduce the interference of noise and
bit error rate. Besides we can also add a suitable device such as match filter at the receiver to
reduce the affection of intersymbol interference (ISI).
Error detection capability
The communication system has the ability of error detection or correction by adding the
channel encoding and decoding to the line code signal.
Transparency
By setting the line code signal and data protocol, we can receive any data sequence accurately.
In this experiment, we will discuss the decoding signals for the different types of line code
signal waveforms taken before.
Figure
Table
Measured results of
Experiment items:
Experiment 1: Unipolar and bipolar NRZ signal decode Experiment 1-1:
Unipolar NRZ signal decode
1. Refer to figure DCS1-1 on ETEK DCS-6000-01 module to produce the UNI-NRZ
signal.
2. To implement a unipolar NRZ decode circuit as shown in figure 2-1 or refer to figure
DCS2-1 on ETEK DCS-6000-01 module.
3. Setting the frequency of function generator to 1 kHz TTL signal and connect this signal
to the Data I/P of figure DCS1-1. Then connect the UNI-NRZ O/P of figure DCS1-1 to
the UNI-NRZ I/P of figure DCS2-1. Next observe on the output waveform by using
oscilloscope and record the measured results in table 2-1.
4. According to the input signals in table 2-1, repeat step 3 and record the measured results
in table 2-1.
Table
Measured results of
4. According to the input signals in table 2-4, repeat step 3 and record the measured results
in table 2-4.
Table
Measured results of
Measured results:
Table 2-1 measured results of UNI-NRZ signal decode
Input Signal Frequencies
(Data I/P)
Data O/P
1 kHz
2 kHz
BIP-NRZ I/P
(Data I/P)
Data O/P
1 kHz
2 kHz
Output waveforms
Test
Point
UNI-RZ
I/P
TP1
TP2
TP3
Output waveforms
Table
Measured results of
Data
O/P
TP4
Output waveforms
Test
Point
BIP-RZ
I/P
TP1
TP2
TP3
Output waveforms
Data
O/P
TP4
Output waveforms
Test
Point
AMI I/P
TP1
TP2
TP3
Output waveforms
10
Table
Measured results of
TP4
TP5
TP6
Data
O/P
TP1
Data O/P
2 kHz
11
5 kHz
12