Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Chapter 1 Introduction
Thank you for choosing our network ip camera.
The Manual can help you to use the camera
correctly.
1.1 Product Appearance.
1.2 Interface.
1 / 24
1.3 Reset.
Its have a button for RESET at bottom of
the device. Click the RESET button by the use
of pencil or other and hold on for 5 second.
2 / 24
Click OK
Click Next
Click Next
3 / 24
Click Next
Click Next
Click Install
4 / 24
Click finsh
2.2 Uninstallation.
Open the control panel for the computer and
find out the MonitorClinet. So you can view its
information from the control panel.
5 / 24
7 / 24
8 / 24
Device:
User:
Pwd:
Video:
the default-value is .
According to the machine model selection.
9 / 24
10 / 24
Flip /Mirror.
: Preset station.
11 / 24
Call station.
12 / 24
Audio
Speaker/ Mic two-ways audio
Record
Snapshot
Exit
13 / 24
14 / 24
4.3 Network
Set the subnet mask, gateway, and DNS server;
following figure check DHCP, the device can
automatically obtain an IP address.
15 / 24
16 / 24
17 / 24
4.6 Email
Sender: input a valid email address to send
pictures when alarm triggered;
SMTP Server the website your mai
l
sender
;
For example QQmail
smtp.qq.com
SMTP Portthe website Port your mailsender
SMTP User and Password: the user and password
of the sender (email account and password).
Receiver: input a valid e-mail address to receive
pictures when alarm triggered. Now it supports
up to 4 receivers.
clickSetting Save the settingsclickRefresh
The new setting is displayed.
18 / 24
4.7 FTP
Ftp service is used to send the captured
pictures when alarm triggered to ftp server and
save them. If the camera is not connected to
the Internet, there is no need to set this function.
FTP Server: the website you want to upload the
picture to;
FTP Port: 21
FTP User: user name to login ftp server;
FTP Password: password to login ftp server;
Upload Interval (Seconds): set the upload
interval;
unit: second.
19 / 24
4.8 DDNS
Acquire a dynamic domain name;
20 / 24
4.9 PTZ
speed:
Amount of patrols:
clickSetting Save the settingsclickRefresh
The new setting is displayed.
21 / 24
4.10 Alarm
Alarm triggered by motion detection:
Moving
4.11 WIFI.
Please clickScan. Then the camera scans
the WLAN nearby and lists the results.you can
fill in the keys according to the wireless network
settings of your wireless router. Select None if
no encryption is set.As its correctly set, please
pull out the network cable and the camera will
reboot. clickSeting Save the settings
clickRefresh The new setting is refreshed.
23 / 24
24 / 24