Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Faculty of Engineering
Mechanical & Production Engineering
Department
Assignment on Boiling
Submitted by:
1. BAPPOO Pallavibaye (1244443)
2. BEEGUN Darvesh (1414993)
3. FAUZEE Bibi Haseenah (1417026)
4. RAMBHUNJUN Roni Noorveer (1415480)
5. RUNGEN Ramalingum Brian (1411458)
1.
2.
Boiling is called pool boiling in the absence of bulk fluid flow, and flow
boiling (forced convection boiling) in the presence of it.
In pool boiling, the fluid is quiescent and its
motion
near
the
surface
is
due
to
free
of
the
vapour
produced
and
the
Figure 3: Example of
flow boiling on the
basis of the presence
of bulk fluid motion.
In case of diabatic flow (e.g. foundin the riser tubes of steam generators
and boiler tubes in power plants or in the coolant channels between
nuclear fuel elements in a boiling water reactor).Boiling occurs on the
walls of the channels and the flow patterns change due to vapour
production as one observes the flow downstream in the channel due to
vapour production.
This is an important difference between pool boiling and flow boiling; i.e.,
that the forced flow of the multiphase system causes flow pattern
transitions at a given wall heat flux (or temperature) as the integral
power deposited in the fluid increases as it flows along the channel.
3.
subcooled
boiling,
the
and
bubbles
saturation
6. Draw the boiling curve and identify the burnout point on the
curve. Explain how burnout is caused. Why is the burnout point
avoided in the design of boilers?
maz
Bibliography
Hyperphysics.phy-astr.gsu.edu. (2016). Vapor Pressure. [online] Available at:
http://hyperphysics.phy-astr.gsu.edu/hbase/kinetic/vappre.html [Accessed 13
Oct. 2016].
Difference Between. (2009). Difference Between Evaporation and Boiling.
[online] Available at: http://www.differencebetween.net/science/differencebetween-evaporation-and-boiling/ [Accessed 13 Oct. 2016].
Different Boiling Regimes and boiling curve. (2016). [Blog] Mechanical
Engineering Design. Available at:
http://mechanicalinventions.blogspot.com/2012/12/different-boiling-regimesand-boiling.html [Accessed 13 Oct. 2016].
Thangavel, M. (2016). Heat and Mass Transfer Basics.
Wins.engr.wisc.edu. (2016). POOL BOILING. [online] Available at:
http://wins.engr.wisc.edu/teaching/mpfBook/node26.html [Accessed 13 Oct.
2016].