Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Seats, front
Tools
Required tools and equipment
VAS5061 Airbag adapter
1- Connector/ignition wire
3- Connector/Ground (GND) wire Golf 1992
72-2
72-3
Removing
- Remove trim strip -1- from inner guide track toward rear.
- Remove wedge -2- on rear side of cap -3- using flat pliers
and remove cap from outer guide tracks.
- Adjust seat forward, press securing clamp -4- together
and remove.
- Slide seat rearward out of guide tracks.
72-4
72-5
Installing
Installation is reverse of removal.
- Check glide pieces -6- (left and right) and front glide piece
-5- for damage, replace if necessary.
- Lubricate glide pieces -6- (left and right) and front glide
piece (multi-purpose grease).
Note:
If the Airbag Malfunction Indicator Lamp (MIL) -K75indicates a malfunction following seat installation, use the
VAG1551 to erase DTC memory and check it again.
Repair Manual, Body On Board Diagnostic (OBD), Repair
Group 01; On Board Diagnostic (OBD) for airbag systems
72-6
72-7
Removing
- Remove front seat
page 72-1 .
72-8
Installing
- Check bushings -12- (left and right) for damage; replace if
necessary.
- Replace Phillips-head screw -11- (with thread locking
compound).
- Remove adhesive residue from nut threads with tap or
thread chaser.
- Coat threads of new screw with locking compound
AMV197 000 01.