Sei sulla pagina 1di 12

Today NTDCL test MCQ's

1 The main Drawback of Feedback system is ______


2 The phase margin of system specifies _____
3 An electrode b/w cathode and anode is called _____
4 In PCM the quantization noise depend on _____
5 Video transmission on TV Broadcast is usually on ______
6 Padders are provided in radio reciever for _____
7 Graphical difference b/w nFET and pFET _______
8 In poison distribution the probability of success is close to____
9 Optical fibers depend on _____ associated with optical receiver.
10 Simple flip flop can be constructed by which gate.
11 _____ cells make concentration layer of lens.
12 Which of communication system is digital?
13 A PWM signal is generated by ___
14 In communication system fidelity is provided by____
15 A balanced modulator produce _____
16 Receiver having poorer IF selectivity will have poorer _____
17 Basically controller is _____
18 Excessive noise in control system may result in _____
19 The decimal number 127 represent ________
20 A programmer would most likely prepare _________
21 Universal gate is ______
22 Radio frequency chokes are air cored to ________
23 Negative maximum of cosine waveform is _______
24 In AC circuit power is consumed by ______
25 Admittance is reciprocal of ________
26 The pole shoes of DC machine are fastened to pole core by___
27 A transformer transform _______
28 Transformer oil must be free from ___________
29 A constant current transformer should not have _____
30 Unit of potential _____
31 In piston maximum temperature at _____
32 Which wire will have high tensile strength ________
33 Which will enter to super heater of boiler ________
34 Which variety of coal has lowest calorific value __________
35 A graphical representation b/w discharge and time is called __
36 Which type test is conducted on isolator.
37 The process of AC to Dc conversion is called ________
38 Green function method is useful technique for ________
39 In outdoor substation the lightening of arrester are placed nearer to _________
40 Which of the following loss of DC motor decrease with increase in load.
41 The _____ field last as long as current flowing in the wire.

1. In PCM, quantization noise depends on


2. Video transmission in TV broadcast uses
3. Padders in radio receiver are used for
4. Filter used for extracting original signal from sampled signal is
5. Structured data that can be used for assessing the system is called
6. When control unit commands ALU to perform an operation, machine cycle is
involved in which step?
7. Matrix order
8. In Poisson distribution, probability of success is very close to
9. Probability of defective bulb is 0.12. Total bulbs are 8000. How many defective
bulbs?
10. Graphical difference between nFET and pFET is
11. Optical power depends on ------- associated with optical fiber receiver.
12. Technology which enables multi broadband signals transmission over single
mode fiber is
13. Simple flip-flop can be constructed from
14. ------- cells make concentration layer of lens.
15. Which of the following is digital communication system?
16. A PWM signal can be generated by
17. Optical fibers operation is based on
18. In communication receivers, fidelity is provided by
19. A balanced modulator produces
20. Receiver having poorer IF selectivity will also have poorer
21. AGC voltage is applied to the stages which are
22. Which one is closes loop system?

23. In position control system, device which provides rate-feedback is


24. Technique not applicable to non-linear systems is
25. Excessive noise in control system may result in
26. A controller is
27. Knowledge of transfer function is needed for
28. Most data communications involving telegraph lines use
29. Which is not true about VHDL?
30. In critically damped system, damping factor of system is
31. If a and b vectors are anti-parallel, then their resultant is
32. Scalar product of parallel vectors is
33. In three phase half-wave diode, ratio of average output to maximum AC voltage
per phase is
34. In thyristor, ------- alternating semiconductor layers and ------- PN functions are
present.
35. A programer does
36. In digital electronics, number of basic operations is
37. 127 can be represented as
38. Which one is universal gate?
39. Mutual induction
40. The form in reference to alternating current waveform represents ratio of
41. When current and voltage are 90 degree out of phase, power is
42. The instantaneous value of sinusoidal AC current at 45 degree is
43. An inductor operates at 50 V AC, 10 kHz frequency and 7.96 mA current. The
value of inductor is
44. Conversion of AC to DC is called
45. In common-base transistor, output is taken from
46. Form factor of 220 V, 50 Hz AC is

47. Radio frequency chokes are air-cored to


48. Max negative peak of cosine wave occurs at
49. In AC circuit, power is dissipated in
50. Admittance is the reciprocal of
51. In DC generator, brushes shift from geometrical neutral position in order to
52. Poles of DC machine are fastened to pole core by
53. Which loss of DC motor decreases with load increase?
54. A tansfromer transforms
55. Transformer oil must be
56. A constant current transformer should not have
57. Unit of potential is
58. If horizontal and vertical components of earth magnetic field are equal, then
angle of dip is
59. The ------- field exists as long as the current is flowing through the wire.
60. Which wave does not require any physical medium for its propagation?
61. Electric dipole moment per unit volume of dielectric is called
62. Green function method is used for
63. In piston, maximum temperature occurs at
64. In super heater of the boiler, ------- enters.
65. Which copper wire has highest tensile strength?
66. In outdoor substation, the lightening arrestors are placed nearer to
67. Which tests are performed on isolators?
68. Which one is suitable for transmitting 3000 kW over 30 km distance?
69. A condenser condenses steam coming out of
70. The lowest calorific value coal is

71. Graph between discharge and time is called


72. Coal is brought to power station by
73. Main drawback of feedback system is
74. Knowledge of transfer function is needed for (repeated)
75. Phase margin of system specifies
76. Non-linearity caused by servometer is
77. In force-voltage analogy, moment of inertia is analogous to
78. At breakaway point, several branches of root loci coalese because the system
characteristic equation has
79. For zener regulation, we dont want zener current to fall below knee current
because
80. A semiconductor device is connected in series with battery and resistance. If
battery polarity is reserved, the
current drops almost to 0. The device maybe
81. For same peak voltage, which waveform will have least rms value?
82. Electrode between cathode and anode is called
83. Greatest possible amplification is achieved in

GENERAL KNOWLEDGE
1.chief minister of Punjab?
Shahbaz sharif
2.How many terms Nawaz sharif served as PM
Three
3.Abdul sattar edhi died after fight with a disease of
Kidney (correct)
4.FIFA world cup 2018 will be held in
Germany
Russia (correct)
Brazil
Qatar (will held 2022 Wc)

5.Who shared the noble peace award 2014 with malala yousafzai
Kailash satyarthi
6.Ishaq dar is
Finance minister
7.Who is curret president of india
Parnab mukherjee
8.Who won the 2015 cricket world cup
Australia
9.Recently religious personality banned by bangladesh
Zakir naik
10.Pak-Iran gas pipeline is
Friendship
Unity
Peace (correct)
11.PTI and Pmln agrreed on election rigging in 2013 to form
JIT
judicial commission (correct)
12. When army public school incident happened
16dec, 2014 (correct)
13. Operation zarb-e-azab was started to get rid of
Terrorism
14. Allai Khwar dam is built by pak in
Kpk
15. Famous ____ Amjad sabri was killed in june 2016
Qawwal
SUBJECT
1. Form factor is the ratio of
Rms value to avg value
Peak value to Rms value
RMS value to peak value
Avg value to peak value

2. Form factor of 220v, 50Hz sinusoidal voltage signal is


1.5
1.14
1.11
0.85
3. Instantaneous value of sinusoidal wave at 45 degree is equal to
RMS Value
Average value
Peak value
Peak to peak value
4. 127 can be written as
0111 1111
1111 1111
1000 0000
1111111
5. The main function of transfer function of any system is to
To get output from input
6. Unit f potential is
Volt
7. Function of transformer is to transform
Power
Current
Voltage
8. If the load of a dc motor increases
Decrease eddy current losses
Core losses
9. Thyristor have __ layers of semiconductors and __ pn junctions
2, 3
3, 4
4, 3
3, 3
10. A semiconductor device is connected to battery, upon changing the polarity of battery the
current reduced to zero, device is
N- type semiconductor
P- type semiconductor
P-N junction

11. Which configuration of transistors have highest gain


Common emitter
Common base
Common collector
None
12. In common base mode the output is taken from
Emitter
Collector
From both
13. In depletion type MOSFET bubble is on
gate
Drain
Source
14. Principle of fiber optics transmission s
Total internal reflection
15. In fiber optics, different consumers multiplexing is done by
Frequency multiplexing
Amplitude multiplexing
Wavelength multiplexing
16.The broadcasting of TV signal is done by
FM
AM
PCM
PWM
17.Lightening arrestor is used after
Isolator
Circuit breaker
Current transformer
Power transformer
18. Which coal has the highest calorific value
Lignite coal
19. In coal power plant coal is carried from storage to boiler is through
V- belts
Trolleys
Buckets
Manually

20. Steam is entered in condenser after leaving from


Turbine
Economizer
Super heater
21. Steam entered into super heater is
Wet steam
Hot steam
Cold steam
22. Of which signal the RMS value is smaller
Sinusoidal
Trianglar
Square
Full-wave rectified
23. Admittance is reciprocal of
Reactance
Impedance
24. Green function used for..........
ordaniary differential equations
partial ode
ist order for
2nd order ode
25. The disadvantage of feedback control system is??
Instability
Inaccuracy
Inefficiency
26. Max value of cosine occurs at
0
90
45
27. Simple J-K flip flop can be built by using
AND
OR
NOR
XOR
28. Transformer Oil should be free from
odour

gases
moisture
29. Number of steps to execute an instruction in Alu??
1 step
2 step
3 step
5 step
30. Padders are used in radio receiver for??
Reducing Losses
31. Success probability in poison distribution?
32. The secondary coil of current transformer should not be ??
33. Universal gate is
Nand
Or
Nor
Xor
34. Probability of the machine being faulty us0.12, how many machines will be faulty in total of
8000 machines??
960
96
9600
35. which filter is must used to get original signal from digital signal
band pass
band stop
high pass
low pass
36. the number of operations used in digital system is
2
3
4
5
37. To transmit 3000 kv for 30km distance wat should be suitable transmission voltage
11kv
33kv

66kv
132kv

NTDC (16 / 10 / 2016) TEST


(Blue Book)
Current Affairs 17 Questions
Q.1 FIFA worldcup 2018 will take place in
a) Germany
b) Russia
c) Brazil
d) Qatar
Q.2 PML (N) and PTI agreed upon rigging in election 2013 on
a) JIT
b) Judicial Commission
c) NAB
d) FIA
Q.3 Nawaz Sharif elected Prime Minister for
a) 2nd
b) 4th
c) 5th
d) 3rd
Q.4 The IranPakistan gas pipeline is also called __________.
A. Friendship pipeline B. Future pipeline C. Peace pipeline D. Unity pipeline
Q.5 Zarb-e-azb operation was carried out to overcome
A. Terrorism
B. Political
C.
D. All of the above

Q.6 Current president of india is


A.
B. Abul kalam Azad
C. Parnab Mukarjee
D. V.P. Singh
Q.7 Current Chief Ministor of Punjab is
A. Shehbaz Shareef
Q.8 Allai Khwr under constructed dam in which province
A. Punjab
B. Balochistan
C. KPK
D. Sindh
Q.9 Muhammad Ishaq Dar is current minister of
B . Finance
Q.10 Famous ___________ Amjad Sabri shot and died in Karachi.
A. Qawwal
Q.11 Attack on APS was took place on
C. 16 Dec 2014
Q. 12 Malala Yousufzai won nobel prize with
D. Kailash Satyarthi
Q. 13 Pakistan beat ______ in 2016 Asia kabaddi cup
C. India
Q. 14 Who won cricket world cup 2015?
B. Australia
Q. 15 Which Islamic scholar recently banned in Bangladesh
C. Zakir Naik
Q. 16 Who declared a law against harassment of children ?
C. UNICEF
Q. 17 Edhi Sb died due to which disease? A. Kidney

Potrebbero piacerti anche