Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
In pulse echo contact method which disply of UT results is recommended when reflecting
surface is rough.
a.
CRT display
b.
c.
Any of a or b are OK
d.
ASME Sec. IX
1.
Essential variable on a welding procedure specification are :(a) those in which a change, as described in the specific variables,
is considered to affect the mechanical properties of the
weldment;
(b) those in which a change, as described in the specific variables, is considered not to affect
the mechanical properties of the weldment;
(c) . both (a) and (b) above are essential variables
(d) They are applicable only if Impact testing of weld is specified.
ANS : (c)
2. The Heat Affected Zone is :(a) that portion of the base metal which has not been melted;
(b) whose mechanical properties or micro structures have been altered by the
heat of welding;
(c) is least likely to contain discontinuities;
(d) both (a) and (b) above.
ANS : (d)
3. A welder may deviate from the parameters specified in WPS if they are nonessential variables
:(a) Provided the change is documented on revised WPS;
(b) Provided the supporting PQR is also revised;
(c) No;
(d) Nonessential variables only apply to PQRs
Ans. a REF : Section IX, QW-200.1
1. A welder is a qualified welder but gives consistently defective weld. What will be your
action as a Quality Control Manager?
Cut his salary to compensate your cost.
Remove him from your company
Discontinue him from the job and retrain and re-qualify him as per code requirements.
d.
5. Tensile test was carried out for qualifying a welding procedure (PQR). The specified minimum
tensile strength of the base metal is 70,000 psi. If the test specimen breaks in parent
metal (outside weld and fusion zone) and the tensile strength calculated is 68,000 psi.
a.
b.
c.
d.
6. A weld procedure is qualified in 1G position. This procedure can be used for welding in
_______ positions
a.
1G
b.
2G
c.
4G
d.
Ans d.
b.
c.
d.
8.
Ans a.
9. When a tensile specimen breaks in the base metal outside of the weld or
fusion line, the strength recorded may be at most ____ below the specified
tensile and be accepted.
A.
3.5%
B.
0.5%
C.
5%
D.
c..
11. What is the number of transverse guided bend tests required for
Performance Qualification in a 6G position?
a. 2
Ans c.
b. 3
c. 4
d. 6
Ans b.