Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Introduction:
Fuse is essentially a small piece of metal connected in between two terminals mounted on
insulated base which forms a series part of the circuit. The objectives of the lab are:
1) To be familiarize with rewireable fuses.
2) To draw time current characteristics curve.
The duty of a rewireable fuse wire is to carry the normal working current safely without heating the
wire but when the normal operating current is exceeded it should rapidly heat up to the melting point
and eventually circuit is opened. It can provide two types of protection.
1. Short circuit protection
2. Over load protection
The melting point follows inverse characteristics between the melting time and the melting current. At
normal rated current the fuse element will never be heated to its melting point. At overloaded current
the melting will occur after certain time. As the amount of overloading is increased the melting time
will be shorter.
Pre-Lab Homework:
Study about rewireable fuses.
Apparatus:
1.
2.
3.
4.
5.
Current Injector.
Clamp on meter.
Rewireable Fuse Wire (2 - 6 A).
Wooden Board fitted with Fuse Holder.
Connecting Wire.
Precautions:
Dept. of EEE, Faculty of Engineering, American International UniversityBangladesh (AIUB)
3. While taking readings of current from the clamp ammeter and current injector
display, justify the readings.
Experimental Procedure:
Connect the current injector set to a 230 V supply line as shown in figure
2.1. There are two output current terminals, one is of 0-20A and other is 0200A. Use 0-20A output terminal. Set the output current at a desired value
by changing the current varying knob. This can only be achieved by
shorting the output terminals by a thick wire. Keeping the knob position at
the desired current value, switch off the current injector and connect the
fuse holder fitted with fuse wire across the output terminals. Then switch
on the injector. The desired current flows through the fuse wire. Measure
the blow out time of the fuse wire. As the increased current flows through
the fuse wire, the fuse blow out time reduces. Measure & record the
currents and the corresponding fuse and blow out time in the table 2.1.
0-20 A output terminal
CURRENT
INJECTOR
BOARD
FITTED
WITH
FUSE
WIRE
230 V
AC
Supply
0-200 A output
terminal
Use the tabulated values in table 1 to plot the value of current (A) against time (s) to obtain
the TCC.
Table
2.1
Sl.
No
1
Current
(A)
2
3
4
5
1. Draw the TCC curve on a graph paper from the data of table 2.1. Use Current in the
X-axis and time in Y-axis.
2. Discuss the special feature for selecting the fuse rating for the protection of motor.
Reference(s):
1. Alexandra Von Meier ,Electric Power Systems: A Conceptual Introduction .
2. Sunil S Rao ,Switchgear Protection and Power Systems .