Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
ai
08/03/2006
10:05:58
CM
EUROCOPTER
AS332
MJ
CJ
L1
CMJ
Technical
Data
332 L1 08.101.01 E
Eurocopter reserves the right to make configuration and data changes at any time without notice.
The facts and figures contained in this document and expressed in good faith do not constitute any offer or contract with Eurocopter
PageTD332L1.pdf
10/01/2008
17:11:16
EUROCOPTER
AS332
L1
Technical Data
SUPER PUMA
(Civil Version)
AS 332 C1 (MK1)
AS 332 L1 (MK1)
EC 225
COUGAR
(Military Version)
Naval version
missiles/torpedoes
Stretched version
utility/armed
AS 532 SC (MK1)
AS 532 AL (MK1)
Utility/armed version
EC 725
Technical Data
Contents
1 - Foreword........................................................................................................... 3
2 - General characteristics .................................................................................. 5
3 - Baseline Aircraft Definition ............................................................................. 10
4 - Recommended Mission Configurations......................................................... 13
5 - Optional equipment ....................................................................................... 17
6 - Main performance ............................................................................................ 25
7 - Customer Service Overview............................................................................ 47
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Blank
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
1- Foreword
The AS332 L1 is a medium weight twin engine helicopter (8,6 tons class) with outstanding
performance that belongs to the famous Super-Puma/Cougar family. Over 661 units, with
total flight time in excess of 3,500,000 Flight Hours have been delivered to date.
The AS332 L1 is a powerful and fast helicopter with long range capabilities. It has a very
large useful volume and accommodates various seating arrangements up to 19 passenger
seats in a spacious cabin and 3 crew members.
Technical advancements developed by EUROCOPTER on the AS332 L1 include modular
design of the mechanical assemblies, use of composite materials, all-weather IFR
capability, even under icing conditions with a special optional equipment, On Condition
maintenance for most of the equipment items and several transmission assemblies and
improvement of the survivability in case of crash.
Fitted with the appropriate equipment, the Super Puma is capable of the following missions
further to the basic passenger transport mission : Internal load or external load carrying,
Casualty evacuation and MEDEVAC missions, Search and rescue and VIP transport
The AS 332 L1 is primarily operated in oil production fields.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Blank
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
2- General Characteristics
Layout
Minimum crew
(D.G.A.C Category A and B certification)
z VFR
: 1 pilot (< 20,000ft Pressure Altitude, with at least one lane of
each autopilot channel engaged) else 2 pilots.
z IFR
: 2 pilots
Passenger transport
(in addition to the crew)
up to 19 comfort seats
VIP transport
(in addition to the crew)
up to 12 seats
Weights
Note : Empty weight accuracy : within 2 %
kg
lb
4,515
9,954
4,085
8,600
4,500
9,350
9,006
18,960
9,920
20,615
Power plant
2 Turbomeca Makila 1A1 turboshaft engines
Engine ratings
Power per engine, in standard atmosphere, at sea level :
kW
1,400
1,330
1,357
1,185
ch
1,902
1,807
1,845
1,610
shp
1,877
1,783
1,819
1,588
US gal.
535
kg
1,595
lb
3,516
254
2 x 257
474
5 x 375
474
560
2 x 567
1,045
5 x 827
1045
litres
2,020
321
2 x 326
600
5 x 475
600
85
2 x 86
158
5 x 126
157
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Main dimensions
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Dimensions of compartments and accesses
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Main Assets
z
Standard cockpit
The cockpit has been designed to accommodate all the flight instruments as well as optional radiocommutation or radio-navigation equipment enabling the aircraft to be flown in IFR conditions.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Blank
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
3-
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.100.01 E
10
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.100.01 E
11
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Blank
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.100.01 E
12
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
13
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Mission configuration
Document
reference
00-10021-A
Commercial
reference
00-10021-00-CI
Name
AS 332 L1 Baseline aircraft as per 332 L1 08.100.01 E
General Equipment
05-01010-A
05-01010-00-CI
CAA kit
05-03005-A
05-03005-00-CI
05-26005-A
05-26005-00-CI
05-31017-A
05-31017-00-CI
Cockpit green tinted panes plus sun vizors with standard colourless panes in
front of the pilot and copilot
05-39001-A
05-39001-00-CI
Map holder
05-50006-A
05-50006-00-CI
Kit for flight in limited icing conditions (submitted approval by local Airworthiness
Authority)
05-51002-A
05-51002-00-CI
05-52004-A
05-52004-00-CI
05-81022-A
05-81022-00-CI
05-82013-A
05-82013-00-CI
Pressure refuelling on the ground usable with maritime sponsons and floatation
gear
05-93003-A
05-93003-00-CI
Naval mooring
05-93005-A
05-93005-00-CI
05-52004-A
05-52004-00-CI
06-21012-00-FP
06-27015-A
06-27015-00-FP
Hydraulic hoist with variable speed 75 meter cable, 272kg (246ft, 600lb) - Fixed
parts
Cargo sling with dynamometer (3 metric tons) - Fixed parts
06-42023-A
06-42023-00-CI
06-60003-A
06-60003-00-CI
2 AERAZUR SR14 self-righting life rafts (with jettison control in cockpit and
survival aid kits) in the sponsons
06-61012-A
06-61012-00-CI
06-64001-A
06-64001-00-CI
Sea anchor
06-65001-A
06-65001-00-CI
06-65009-A
06-65009-00-CI
2 Flashlights
06-66003-A
06-66003-00-CI
06-67013-A
06-67013-00-CI
06-67020-A
06-67020-00-CI
06-69001-A
06-69001-00-CI
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
14
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Document
reference
Commercial
reference
Name
Interior Layout
07-10006-00-CI
07-25020-00-CI
07-30011-00-CI
07-60003-00-CI
08-00017-B
08-00017-01-CI
08-12024-A
08-12024-00-CI
08-16032-A
08-17043-A
08-27031-A
08-31001-A
08-16032-00-CI
08-17043-00-CI
08-27031-00-CI
08-31001-00-CI
08-43004-A
08-43004-00-CI
08-73001-A
08-73001-00-CI
08-83006-A
08-83006-00-CI
EUROHUMS
07-10006-A
07-25020-A
07-30011-A
07-60003-A
Avionics
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
15
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Blank
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
16
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
5- Optional equipment
Note : value of the weight breakdown is given for information and shall no t be considered as contractual.
Commercial
reference
Document
reference
Name
kg
lb
General equipment
05-01010-A
05-01010-00-CI
CAA kit
7.5
16.5
05-03005-A
05-03005-00-CI
2.0
4.4
05-21012-A
05-21012-00-FP
3.0
6.6
05-21012-A
05-21012-00-RP
9.9
21.8
05-22009-A
05-22009-00-CI
62.0
136.7
05-25012-A
05-25012-00-CI
0.3
0.7
05-25013-A
05-25013-00-CI
0.1
0.2
05-26005-A
05-26005-00-CI
14.0
30.9
05-31017-A
05-31017-00-CI
3.4
7.5
05-31018-A
05-31018-00-CI
3.4
7.5
05-31020-A
05-31020-00-CI
0.0
0.0
05-31022-A
05-31022-00-CI
0.0
0.0
05-31024-A
05-31024-00-CI
1.0
2.2
05-32006-A
05-32006-00-CI
Windshield washers
1.5
3.3
05-39001-A
05-39001-00-CI
1.0
2.2
05-42009-A
05-42009-00-CI
100.0
220.5
05-42009-A
05-42009-01-CI
82.7
182.3
05-50004-A
05-50004-00-CI
145.0
319.6
05-50005-A
05-50005-00-CI
56.1
123.7
05-50006-A
05-50006-00-CI
2.0
4.4
05-51002-A
05-51002-00-CI
11.0
24.3
05-52004-A
05-52004-00-CI
3.0
6.6
05-62008-A
05-62008-00-CI
22.0
48.5
05-67006-A
05-67006-00-CI
0.0
0.0
05-80004-A
05-80004-00-CI
85.8
189.2
1
2
332 L1 08.101.01 E
17
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Commercial
reference
Document
reference
Name
kg
lb
05-81010-00-CI
27.5
60.6
05-81011-A
05-81011-00-CI
134.5
296.5
05-81022-A
05-81022-00-CI
21.9
48.3
05-81024-A
05-81024-00-CI
109.5
241.4
05-81026-A
05-81026-00-FP
On Request
05-81026-A
05-81026-00-RP
On Request
05-82012-A
05-82012-00-CI
18.1
39.9
05-82013-A
05-82013-00-CI
12.4
27.3
05-82014-A
05-82014-00-CI
15.6
34.4
05-84006-A
05-84006-00-RP
23.9
52.7
05-84007-A
05-84007-00-CI
35.5
78.3
05-86002-A
05-86002-00-CI
0.0
0.0
05-92005-A
05-92005-00-FP
6.4
14.1
05-92005-A
05-92005-00-RP
50.9
112.2
05-93003-A
05-93003-00-CI
Naval mooring
3.7
8.2
05-93005-A
05-93005-00-CI
1.0
2.2
05-94001-A
05-94001-00-CI
4.5
9.9
15.0
33.1
103.0
227.0
45.0
99.2
06-20002-00-FP
06-20002-A
06-20002-A
06-21012-A
06-21012-00-FP
6.9
15.2
06-21012-A
06-21012-00-RP
47.8
105.4
06-21024-A
06-21024-00-FP
13.0
28.6
06-21024-A
06-21024-00-RP
103.0
227.0
06-25003-A
06-25003-00-CI
Drip tub
7.0
15.4
Needs to procure the hydraulic circuits linkage sold as reference tools n332A.95.4000.00.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
18
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Commercial
reference
Document
reference
Name
kg
lb
06-26005-00-CI
6.5
14.3
06-27015-A
06-27015-00-FP
8.8
19.4
06-27015-A
06-27015-00-RP
22.1
48.7
06-27017-A
06-27017-00-FP
4.1
9.0
06-27017-A
06-27017-00-RP
23.9
52.7
06-31017-A
06-31017-00-FP
15.1
33.0
06-31017-A
06-31017-00-RP
25.8
56.7
06-42010-A
06-42010-00-CI
5.0
11.0
06-42023-A
06-42023-00-CI
3.5
7.7
06-43004-A
06-43004-00-CI
6.7
14.8
06-45014-A
06-45014-00-FP
4.9
10.8
06-45014-A
06-45014-00-RP
24.0
52.9
06-51020-A
06-51020-00-CI
FLIR
On Request
06-60003-A
06-60003-00-CI
128.0
282.2
06-61012-A
06-61012-00-CI
196.6
433.5
06-61014-A
06-61014-00-FP
Emergency floatation gear, usable with external fuel tanks Fixed parts
25.9
57.1
06-61014-A
06-61014-00-RP
Emergency floatation gear, usable with external fuel tanks Removable parts
151.5
334.0
06-64001-A
06-64001-00-CI
Sea anchor
2.9
6.4
06-65001-A
06-65001-00-CI
2.2
4.9
06-65009-A
06-65009-00-CI
1.2
2.6
06-66003-A
06-66003-00-CI
5.3
11.7
06-67013-A
06-67013-00-CI
2.1
4.6
06-67020-A
06-67020-00-CI
7.6
16.8
06-68005-A
06-68005-00-CI
0.5
1.1
06-69001-A
06-69001-00-CI
1.3
2.9
06-81022-A
06-81022-00-CI
450.0
992.0
1
2
3
Requires to remove the central auxiliary fuel tank if it has been selected by the user
Required for JAR OPS 3.
Acceptance by local airworthiness authorities to be checked.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
19
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Commercial
reference
Document
reference
Name
kg
lb
Interior layout
07-10006-A
07-10006-00-CI
18.2
40.1
07-25020-A
07-25020-00-CI
196.7
433.6
07-25022-A
07-25022-00-CI
209.2
461.2
07-30009-A
07-30009-00-CI
07-30011-A
07-30011-00-CI
07-50013-A
07-50013-00-CI
07-50015-A
07-50015-00-CI
07-50021-A
07-50021-00-CI
07-60003-A
07-60003-00-CI
07-60004-A
On Request
157.0
346.1
7.0
15.4
15.0
33.1
8.3
18.3
48.6
107.1
07-60004-00-CI
40.0
88.2
07-70001-A
07-70001-00-CI
210.4
463.9
07-70016-A
07-70016-00-CI
On Request
07-71014-A
07-71014-00-CI
28.9
63.7
07-74010-A
07-74010-00-CI
8.3
18.3
07-80004-A
07-80004-00-CI
07-80005-A
07-80005-00-CI
580.0
1278.7
07-80012-A
07-80012-00-CI
555.0
1223.6
07-82008-A
07-82008-00-CI
Retractable armrests
On Request
07-82009-A
07-82009-00-CI
Lombar adjustment
On Request
07-83001-A
07-83001-00-CI
Electric curtains
On Request
07-84003-A
07-84003-00-CI
On Request
07-85007-A
07-85007-00-CI
On Request
07-91001-A
07-91001-00-CI
1
2
3
4
On Request
2.0
4.4
Installation including 17 comfort seats and the cushions of the 3 bench seats integrated in the cabin bulkhead.
Recommended in VIP configuration.
The removable parts of present complete installation are not certified.
Equipment is not certified
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
20
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Corporate
VIP
Passenger transport
Crew change
Seating
10 seats
VIP
or
19 comfort
seats
19 comfort
places
11 seats
VIP
or
10 + 2 seats
VIP
Rear
Standard
Luggage hold with
bench seat
Standard upholstery
or
or
Rear
built-in step door
Airline upholstery
VIP upholstery
Doors
and
Special RH double
door
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
21
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Document
reference
Commercial
reference
Name
kg
lb
Avionics
08-00017-B
65.3
144.0
Collins - VHF22A #1
Collins - VHF22A #2
ICS - Basic set : 3 control panels CP 1976 in cockpit
Thales - AHV16 - Radio altimeter with indicator IND 201
Collins - TDR94D - Transponder Elementary Surveillance
(including flight identification)
Collins - ADF 60 - ADF #1
Collins - DME 42 - DME
Collins - VIR 32 - VOR/ILS/MKR #1
Collins - VIR 32 - VOR/ILS/MKR #2
Shadin - 8800T - Altitude encoder
08-00018-C
On Request
Collins - VHF22A #1
Collins - VHF22A #2
ICS - Basic set : 3 control panels CP 1976 in cockpit
ICS - Complementary set : 4th control panel CP 1976 in cabin
Thales - AHV16 - Radio altimeter
Thales - AHV16 - 2nd Radio altimeter
Collins - TDR94D - Transponder Elementary Surveillance
(including flight identification)
Collins - ADF 462 - ADF #1
Collins - DME 442 - DME
Collins - VIR 432 - VOR/ILS/MKR #1
Collins - VIR 432 - VOR/ILS/MKR #2
Telephonics - 1500B - Search Radar with 9 inches display
Canadian Marconi - CMA 3024 - GPS receiver
Canadian Marconi - CMA 9000 - Flight Management System with
SAR mode
Collins - MFD255 - Displays (Qty 4)
Marconi - ANV 353 - Doppler Radar
Sagem Avionics (ex-Sfim) - CDV 155 - Flight director coupler
The radio/com/nav. equipment weight figures included in this chapter are average values. As the installation of those equipment may vary
from one a/c to an other, the weight of a complete configuration with multiple items may not be the simple sum of all individual weights.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
22
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Document
reference
Commercial
reference
Name
kg
lb
08-12024-A
08-15515-A
08-16032-A
08-17002-A
08-17012-A
24.3
53.6
5.0
11.0
On Request
3.1
6.8
25.0
55.1
1.6
3.5
08-18030-A
0.5
1.1
08-24004-A
6.4
14.1
08-27021-A
8.0
17.6
08-27031-A
5.4
11.9
08-31001-A
28.0
61.7
08-43004-A
3.5
7.7
08-73001-A
15.2
33.5
08-81014-A
35.0
77.2
08-83006-A
08-83006-00-CI EUROHUMS 3 4
53.8
118.6
The radio/com/nav. equipment weight figures included in this chapter are average values. As the installation of those
equipment may vary from one a/c to an other, the weight of a complete configuration with multiple items may not be the
simple sum of all individual weights.
1
2
3
4
332 L1 08.101.01 E
23
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Blank
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
24
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
6- Main performance
The following performance values and figures refer to an AS332 L1 equipped with new engines.
Unless otherwise specified, the values and figures refer to a clean helicopter at Sea Level (SL), in
International Standard Atmosphere (ISA) and zero wind condition.
Performance on 2 engines
Gross Weight
kg
lb
Rate-of-climb at 70 kts
ISA + 20C
ISA + 20C
ISA + 20C
Maximum range
(without fuel reserve, at recommended cruise speed)
z
with standard fuel tanks
z
Maximum endurance
(without fuel reserve, at 130 km/hr (70 kts))
z
with standard fuel tanks
z
with external fuel tanks
z
with central auxiliary fuel tanks
z
z
z
6,000
13,230
7,000
15,430
8,000
17,630
8,600
18,960
304
164
283
153
265
143
481
1,060
335
739
14.7
2,894
303
164
281
152
262
141
486
1,071
353
778
12.1
2,382
298
161
278
150
258
139
497
1,096
374
825
9.8
1,920
278
150
262
141
252
136
502
1,107
389
858
8.2
1,618
m
ft
m
ft
6,500
21,325
5,850
19,193
5,100
16,732
4,450
14,560
3,950
12,959
3,200
10,499
3,250
10,663
2,300
7,546
m
ft
m
ft
5,750
18,865
5,200
17,060
4,300
14,108
3,550
11,647
3,050
10,007
2,100
6,890
2,300
7,546
1,400
4,593
7,200
5,900
4,650
>2,895
ft
m
ft
23,622
6,500
21,325
19,357
5,100
16,732
15,255
3,800
12,467
>9,500
2,895
>9,500
km
nm
km
n.m
km
n.m.
km
n.m.
km
n.m.
km
n.m.
736
397
664
358
724
391
652
352
624
337
592
319
879
474
1148
620
1021
551
1192
644
1164
628
1132
611
859
464
1127
609
1000
540
1267
684
1528
825
1662
897
841
454
1105
596
979
529
1105
597
1105
597
1976
1067
hr : min
hr : min
4:08
3:46
4:49
6:26
4:34
6:06
4:24
5:54
hr : min
hr : min
4:04
3:42
3:32
3:21
5:38
6:41
6:32
6:21
5:20
6:53
8:23
9:09
5:09
6:39
8:06
10:46
km/hr
kts
km/hr
kts
km/hr
kts
kg/hr
lb/hr
kg/hr
lb/hr
m/sec.
ft/min.
hr : min
hr : min
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
25
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Performance in external load
(maximum gross-weight of 9,350 kg 20,615 lb)
6.4 m/sec
1,260 ft/min
650 m
2,133 ft
ISA + 10C
300 m
984 ft
ISA + 17C
Sea level
Performance on 1 engine
kg
lb
Gross Weight
6,000
13,230
7,000
15,430
8,000
17,630
8,600
18,960
9.0
1,772
6.8
1,339
4.7
925
3.4
669
m
ft/min
m
ft
5,200
17,060
3,700
12,139
2,500
8,202
1,800
5,906
m
ft
4,500
14,764
3,050
10,007
1,750
5,741
950
3,117
>50
>50
>50
40
ISA + 20C
kg
lb
7,500
16,534
6,900
15,211
In hover OGE
kg
lb
6,910
15,233
6,320
13,933
Operating limitations
The helicopter is cleared to be operated within the following altitude and temperature limitations
(according to Flight Manual). For complementary information, refer to Flight Manual:
Maximum altitude
Flight
M < 8,350 kg :
M > 8,350 kg :
z Take-off and landing :
7,620 m 25,000 ft
2,895 m 9,500 ft
4,572 m 15,000 ft
Maximum temperature
Minimum temperature
- 30C (basic)
Pressure Altitude
Pressure Altitude
Density Altitude
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
26
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
- 45C (with optional installation for flight in extreme cold weather)
Abbreviations
AEO :
AGL :
DA :
IGE :
ISA :
MCP :
OEI :
OGE :
PA :
SL :
TAS
TOP :
VNE :
VTOL :
Vtoss :
Vy :
Vz :
Sea Level
True Air Speed
Take-Off Power
Never Exceed Speed
Vertical Take-Off and Landing
Take-off safety speed
Optimum climbing speed
Rate-of-climb
Units
nm :
kts:
ft/min :
m/sec :
C:
nautical miles
knots
feet/minute
meters per second
degrees Celsius
hr:min :
kg :
lb :
km :
hours:minutes
Kilograms
pounds
kilometers
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
27
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Blank
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
28
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Performance charts
The performance charts presented hereafter apply to an aircraft as per the standard definition.
Page 31
Page 32
Page 33
Page 34
Page 35
Page 36
Page 37
Page 38
Page 39
Page 40
Page 41
Page 42
Page 43
Page 44
Page 45
Page 46
Page 47
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
29
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
TAKE-OFF WEIGHT IN HOVER IGE (HEIGHT = 10 FT)
(10 ft, on 2 engines, at take-off power or maximal torque, no wind)
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
30
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
TAKE-OFF WEIGHT IN HOVER OGE
(on 2 engines, at take-off power or maximal torque, no wind)
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
31
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
MAXIMUM CRUISE SPEED
Pitch: 165 for weight 8,350 kg - 18,410 lb
Pitch: 16 for weight > 8,350 kg - 18,410 lb
ISA
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
32
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
MAXIMUM CRUISE SPEED
Pitch: 165 for weight 8,350 kg - 18,410 lb
Pitch: 16 for weight > 8,350 kg - 18,410 lb
ISA + 20C
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
33
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
RECOMMENDED CRUISE SPEED
Pitch: 155
ISA
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
34
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
RECOMMENDED CRUISE SPEED
Pitch : 155
ISA + 20C
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
35
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
RATE-OF-CLIMB IN OBLIQUE FLIGHT
(on 2 engines, at best climb speed)
ISA
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
36
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
RATE-OF-CLIMB IN OBLIQUE FLIGHT
(on 2 engines, at best climb speed)
ISA + 20C
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
37
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
RATE-OF-CLIMB IN OBLIQUE FLIGHT
(on 1 engine, at intermediate emergency power)
ISA
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
38
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
RATE-OF-CLIMB IN OBLIQUE FLIGHT
(on 1 engine, at intermediate emergency power)
ISA + 20C
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
39
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
HOURLY FUEL CONSUMPTION
AT MAXIMUM CRUISE SPEED
(pitch 165)
M 8350 kg
ISA
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
40
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
HOURLY FUEL CONSUMPTION
AT MAXIMUM CRUISE SPEED
(pitch 16)
M > 8350 kg
ISA
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
41
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
HOURLY FUEL CONSUMPTION
AT MAXIMUM CRUISE SPEED
(pitch 165)
M 8350 kg
ISA + 20C
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
42
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
HOURLY FUEL CONSUMPTION
AT MAXIMUM CRUISE SPEED
(pitch 16)
M > 8350 kg
ISA + 20C
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
43
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
HOURLY FUEL CONSUMPTION
AT RECOMMENDED CRUISE SPEED
ISA
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
44
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
HOURLY FUEL CONSUMPTION
AT RECOMMENDED CRUISE SPEED
ISA + 20C
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
45
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
46
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
47
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Inspection Program
The Maintenance Program specifies the intervals between maintenance operations that are
recommended by Eurocopter, irrespective of whether they are mandatory or not.
The program can:
either be used as is,
or be adapted by each operator to suit his own specific organization, provided he complies with the
maximum intervals.
The following table provides an overview of all inspections. Scheduled inspections with shorter time
intervals have to be added to those with longer time intervals.
Daily checks :
Pilots task
13 MMH
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
48
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Main components
Time Between Overhaul (TBO) / Service Life Limit (SLL) 1
TBO (h)
Main Components
Alternator 40 KVA
5000
Hydraulic Pump
3000
Booster Pump
2000
SLL (h)
20000
1500
11000
Coupling Shaft
4800
3000
3000
3000
3000
9500
3500
3500
3400
3000
Main Components
TBO (h)
MAKILA 1A1
SLL (h)
3000
Main component values are given for information purposes only. The reference document is the aircraft
Maintenance Program Manual.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
49
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Eurocopter Maintenance Support Programs
EUROCOPTER offers its clients a comprehensive array of repair and overhaul services to ensure availability
and costs control. This array of services ranges from basic OEM repair and overhaul services up to
comprehensive Parts By the Hour (PBH) maintenance programs.
The different services are each tailored for one different user profiles and demands, such as customers:
with a high number of flight hours,
with a low number of flight hours,
looking for immediate component availability,
that wish budget control,
To respond to the different customers demands EUROCOPTER offers the following flexible and modular
services:
Classic Support
Maintenance, Repair and Overhaul
Standard exchange
Guaranteed Direct Maintenance Costs (DMC)
Unscheduled Maintenance Insurance Plan
Parts by the Hour service
On request, Eurocopter is able to propose extensive services adapted to specific mission and customer
expectations, as stock and maintenance management.
Classic Support
The classic support consists of a comprehensive Initial Provisioning package to sustain aircraft operation. This
package includes Spare Parts, Tools, Test Equipment, etc...
The required level of operational availability determines the quantity and therefore the investment required.
With this support package the Customer bears the responsibility to monitor their repair; manage obsolescence
and to procure the right mix and quantity of components and spare parts.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
50
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Standard Exchange
The Standard Exchange consists in replacing a defective part with a serviceable and interchangeable part
within 48 hours subject to availability. This service is available for equipment, blades and dynamic
components.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
51
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Engine Maintenance program
Always looking to maximize your efficiency and reduce your costs, Turbomeca, the engine
manufacturer has developed an improved service offering.
Turbomeca has 32 Repair Centers across the globe, supplemented by several new factory-authorized
service facilities strategically located near to you
Turbomeca range of services covers:
Classic Repair and Overhaul
Standard Exchange
AOG services
Support By the Hour (SBH) services
Within the Support By the Hour coverage Turbomeca developed specific maintenance packages, as
summarized hereafter.
Standard Coverage: Classic SBH
The classic Support by the Hour (SBH) is a global support service offered to operators to enable
them to maintain the best availability of their engines fleet through a contract arrangement paid by
running hours.
The Support by the Hour (SBH) is operated mainly through Standard Exchange supported by
Turbomeca dedicated Corporate Pool.
Customized Coverage: SBH Mission
The new service, Support By the Hour Mission, offers a modular series of comprehensive service and
engine management packages whereby Turbomeca undertakes to guarantee its operator's engine
availability and care.
From basic engine support requirement to fully comprehensive range of additional services, three
different types of packages are offered to operators : Pro, Prime and Privilege.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
52
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Training
With more than 50 years of experience, the Eurocopter training centers provide the most
comprehensive, coherent and highest standard helicopter training in the world for pilots and
technicians, whether civilian or military.
Qualification training, allowing operators to comply with regulatory requirements, and services training,
more mission oriented and tailored to the customers operational needs, are addressed.
All training courses are established according to the relevant civil aviation authorities requirements.
The centers are approved by the relevant airworthiness authorities (EASA, FAA, DGAC, LBA, CAA).
We are certified ISO 9001: V2000 and regularly audited by independent organisms such as Vritas,
AFAQ
Eurocopter training centers provide a wide range of courses and services, from basic training up to
preparation for the most sophisticated civil and military missions.
As part of the full range of services on offer, Eurocopter also plays an active role in helicopter pilot
development through its Ab Initio programs.
Centers are equipped with multimedia classrooms. This includes computers overhead projectors and
state-of-the-art means such as Computer Aided Instruction (CAI), Computer Based Training (CBT).
Some centers also have self-learning laboratories.
Eurocopter has set up a network of 14 training centers. For detailed information refer to Eurocopter
specific publication.
COURSE REFERENCE
THEORETICAL
INSTRUCTION
FULL
FLIGHT
FLIGHT
INSTRUCTION
SIMULATOR
Pilots
COURSE
TYPE
(1)
COURSE REFERENCE
10 days
10 1/2 hours
2 hours
6 Hours
2 hours
5 weeks
Type Rating
Maintenance and repair
4 weeks
2 weeks
(1) Pilot already qualified on AS332 L1 (mini 15 hours, within last 12 months, not included in Type
Rating.
Note: length is given as information and depends on pilot or technician qualification or experience.
Complementary courses may be required.
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
53
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
Technical Data
Engine Training Courses
Training courses dedicated to Engine Maintenance is also organized by Turbomeca training schools
and approved centers the world over
Up-to-date course calendars, on-line tests and e-learning modules are also available on the Turbomeca
Operator On-Line Support (TOOLS site)
Technical publications
Eurocopter provides all the technical publications necessary for safely operating and maintaining its
aircraft cost effectively.
Eurocopter technical publications are available on an interactive electronic medium as a standard or in
hard copies as an option.
The OPEN DVD-ROM includes the Maintenance Program (PRE), the Maintenance Manual (MET), the
Wiring Diagram Manual (MCS), the Description and Operation Manual (MDF), the Fault and Isolation
Manual (MFI), the Storage and Preservation Manual (MST), the Repair Manual (MRR), the Standard
Practices Manual (MTC) and the Illustrated Parts Catalogue (IPC).
The component maintenance manual (CMM) is available on DVD-ROM or hard copy, depending on the
Vendor.
Along with the OPEN DVD-ROM, Eurocopter provides a hard copy of the Airworthiness Technical
Publication (Flight Manual, Pilots Check List, Master Servicing Manual ) as well as the Service
Bulletin Catalogue.
The DVD ROM is available in English or French; it includes the latest information and is updated every
6 - 9 months
Tlex Alert, Tlex Information, Service Bulletin, Service Letter, Service Information, Technical Information
Letter
List of Applicable Publications (LOAP)
List of Master Minimum Equipment List (MMEL)
Main features
The data set forth in this document are general in nature and for information purposes only. They may vary with conditions.
For performance data and operating limitations,reference must be made to the approved flight manual and all appropriate documents.
332 L1 08.101.01 E
54
This document is the property of EUROCOPTER ; no part of it shall be reproduced or transmitted without the express prior written authorization of EUROCOPTER and its contents shall not be disclosed. EUROCOPTER - 2008
EU ROCO PTER
EC120
Technical
Data
120 B 07.101.01 E
Eurocopter reserves the right to make configuration and data changes at any time without notice.
The facts and figures contained in this document and expressed in good faith do not constitute any offer or contract with Eurocopter