Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
INSTALLATION INSTRUCTIONS
APPLICATION
This document covers the mounting and wiring of the
NPB-2X-RS485 option card into a WEBs-AX or CP controller
(WEB/CP-201/600/700, SEC-H-201/600, or WEB/CP-202/
602-XPR series).
TX R X
s RS
485
TX R X
COM3 / COM5
COM7
See Notes in
Table 1.
COM4 / COM6
COM8
95-7778-01
Preparation
Examine the component side of the option card to locate the
bias resistor jumper pins. See Fig. 2. You may wish to enable
biasing for either (or both) RS-485 ports before mounting the
card.
MOUNTING
WARNING
1
ENABLE
BIAS
TO BIAS
THIS PORT
TO BIAS
THIS PORT
1.
2.
NOTE: If accessory modules are plugged into the controller, you may need to slide them away from
the unit to get to the cover tabs.
3.
4.
Battery
Assembly
Screws (4)
(includes
cable and
bracket)
Blanking
End
Plate
Option Slot 2
Area
WEB/CP-201/600/
700
Option Slot 1
Area
95-777801
5.
Remove the blanking end plate for the slot you are
installing the option card into.
(Retain the blanking end plate in case the option card
must be removed at a later date.)
6.
7.
8.
11.
WIRING
10.
WEB/CP-201/
600/700
WEB/CP
Battery
Connector
WEB/CP-201/
600/700
9.
LEDS
Four LEDs are visible on the top of the NPB-2X-RS485 option
card (cover must be removed from controller). They are also
noted on the label as TX and RX. See Fig. 1 on page 1.
The four LEDs (two for each port) are described as follows:
TX (yellow) Transmit, indicates that the controller/option
card is sending data to a device.
RX (green) Receive, indicates that the controller/option
card is receiving data from a device.
95-777801
Table 2. COM Port Assignments Based on Controller and Option Card Configuration.
Card Slot 1
Controller Model
SEC-H-201/600
Slots Used
1 only
1 and 2
WEB/CP-201/600
WEB/CP-202/602-XPR
NPB-2X-RS485
COM3 COM4
COM3 COM4
NPB-2X-RS485
COM5 COM6
1 and 2
NPB-GPRS
COM3
NPB-2X-RS485
COM4 COM5
1 only
NPB-2X-RS485
COM3 COM4
COM3 COM4
1 and 2
NPB-2X-RS485
COM3 COM4
NPB-RS232
COM5
1 and 2
NPB-2X-RS485
COM3 COM4
NPB-2X-RS485
COM5 COM6
1 and 2
NPB-GPRS
COM3
NPB-2X-RS485
COM4 COM5
1 only
NPB-2X-RS485
COM5 COM6
1 and 2
NPB-2X-RS485
COM5 COM6
NPB-RS232
COM7
1 and 2
NPB-2X-RS485
COM5 COM6
NPB-2X-RS485
COM7 COM8
1 only
NPB-2X-RS485
COM7 COM8
COM Ports
NPB-2X-RS485
WEB/CP-202/602-XPR Controller
1 and 2
2 only
WEB/CP-700
COM Ports
COM3 COM4
Card Slot 2