Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Installation
Guide
www.volktek.com
Contents
Preface ..................................................................................................... 3
Support .................................................................................................... 3
Related Documentation ............................................................................... 3
1.
1.1.
Unpacking .............................................................................................. 4
1.2.
1.3.
1.4.
1.5.
LEDs ...................................................................................................... 8
2.
Software Configuration........................................................................ 9
2.1.
2.1.1.
2.1.2.
Console .......................................................................................... 10
2.2.
2.3.
2.4.
Preface
This manual is the installation guide for MEN-4210 and contains the following
sections:
Hardware Installation
Unpacking
Product Layout
Connecting AC/DC/Battery power
Installing SFP modules and Fiber cable
LEDs
Software Configuration
Switch Access through
Web-based management interface
Console
Hyper terminal
Configuration Backup/restore
Reset to factory default configuration
Firmware upgrade
Support
For any assistance with this product, please visit Support section of
www.volktek.com website. Also, you can contact us by email: support@volktek.com
Related Documentation
Support Notes
Configuration Guide
Troubleshooting Guide
Hardware Installation
1. Hardware Installation
1.1. Unpacking
Open the package and carefully unpack the switch
The box should contain following items*:
One MEN-4210 8-port 10/100, 1-Gigabit SFP and 1-100FX/Gigabit SFP, L2
Managed switch
One Console Cable DB9 (RS232)
One AC power cord
One user manual cd
Accessories pack Rack-mount rubber foot, bracket, screw etc.
* Content can be adjusted based on customer demand
Package
Console Cable
AC Power cord
Rubber foot
User Manual CD
Hardware Installation
A/C Power
Reset Button
Console Port
Rear View
The rear view panel of the MEN-4210 consists of Battery connector and 15V DC jack.
Battery connector
15V DC Jack
Hardware Installation
AC
DC
Battery
Hardware Installation
Slide the selected SFP module into the selected SFP slot (Make sure SFP
module is aligned correctly with the SFP slot)
Insert and slide the module into the SFP slot until it clicks into place
Remove any rubber plugs that may be present in SFP modules mouth
Align the Fiber cables connector with SFP modules mouth and insert the
connector
Hardware Installation
1.5. LEDs
The LEDs on the MEN-4210 are as below:
Condition
Status
On (Green)
Off
Flashing (Green)
On
On (Green)
Flashing (Green)
Off
PWR
POST
LNK/ACT
(1 to 8 copper
ports and 9th, 10th
SFP port)
Software Configuration
2. Software Configuration
2.1. Switch Access
2.1.1. Web-based management interface
MEN-4210 Default settings:
Software Configuration
2.1.2. Console
Steps to access the switch through console port:
10
Software Configuration
Console login through putty:
After connecting console cable to MEN-4210 console port and your computers serial
port,
Go to Device manager
Scroll to Ports USB Serial Port (COM#) Make a note of COM#
Run Putty
Type the COM# in serial line (e.g. COM5 as shown in the figure)
Set the speed to 38400
Click Open
A session is opened and displays the CLI as shown in the figure below to configure the
desired settings
11
Software Configuration
12
Software Configuration
Use the following command to reset the switch to its factory default
configuration settings
Factory default
configuration
13