1) How many wattmeter required for n conductor network with common point is not on line a) n b) n-1 c) n-2 d) n+1 ans: a 2) How many wattmeter required for n conductor network with common point is on line a) n b) n-1 c) n-2 d) n+1 ans: b 3) Measurement in 3 phase can be done by using a) 2 wattmeter b) 3 wattmeter c) 1 wattmeter d) all ans: d 4) Active power is donated by a) R b) P c) S d) Q ans: b 5) Reactive power is donated by a) R b) P c) S d) Q ans: d 6) Apparent power is donated by a) R b) P c) S d) Q ans: c 7) Active power is equal to a) VI sin b) VI cos c) VI d) VI tan ans: b 8) Reactive power is equal to a) VI sin b) VI cos c) VI d) VI tan ans: a 9) Apparent power is equal to a) VI sin b) VI cos c) VI d) VI tan ans: c 10) For a given load tan= a) Q/P b) Q*P c) Q+P d) Q-P ans: a 11) If p1 & p2 reading of wattmeter in 2wattmeter method then tan= a) 3 (p1-p2)/(p1*p2) b) 3 (p1+p2)/(p1*p2) c) 3 (p1*p2)/(p1-p2)d) 3 (p1-p2)/(p1+p2) ans: d 12) Auto transformer is used in polyphase Varmeter for a) current shift b) voltage shift c) voltage amplification d) current amplification ans: b 13) In 3 phase wattmeter torque is proportional to
a) p1-p2 b) p1+p2 c) p1/p2 d) p1*p2
ans: b 14) Transformation ratio is donated by a) R b) Kn c) n d) RCF ans: a 15) Nominal ratio is donated by a) R b) Kn c) n d) RCF ans: b 16) Turn ratio is donated by a) R b) Kn c) n d) RCF ans: c 17) Ratio correction factor is a) R*Kn b) R/Kn c) R+Kn d) R-Kn ans: b 18) Disadvantage of shunt at high currents a) bad accuracy b) high power consumption c) isolation d) all ans: d 19) Disadvantage of multiplier at high voltages a) high power consumption b) shielding c) a & b d) none ans: c 20) Clamp on meter are used a) to measure current b) for accuracy c) a & b d) none ans: a