TABLE RCB-7.133 TUBESHEET THICKNESS FOR SHEAR Note: Must be calculated for shell side or tube side pressure, whichever is controlling.
0 = Outside tube diameter, Pitch = Tube spacing,
inches (mm). For integrally center-to-center, inches finned tubes, the OD of the (mm). tube in the tubesheet shall be used.
= Code allowable stress in
tension, psi (kPa). For tubesheet material at design metal temperature. (See parag raph RCB-1 .42.)
p (a)
Design pressure, psi (kPa), shell side ar tu be
side, corrected far vacuum when present an appasite side, ar differential pressure when specified by custamer
(b)
Design pressure, psi (kPa), shell side ar tu be
side, carrected far vacuum when present on oppasite side, or differential pressure when specified by custamer
(e)
C=
Perimeter of tube layout
measured stepwise in increments of one tube-to-tube pitch center-to-center of the outermost tubes, in inches (mm). See Figure RCB-7.133
total area enclosed by e
in square inches (mm 2). See Figure RCB-7.133
Design pressure, psi (kPa), shell side ar tube
side, corrected far vacuum when present an oppasite side, or differential pressure when specified by custamer, ar for fixed tubesheet type units, as defined in paragraphs RCB-7.163 thru RCB-7.165
TABLE RCB-7.133 Cantinued next page
Standards Of The Tubular Exchanger Manufacturers Association