Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
PART# PW010035
BRACKETS FOR 70" RUNNING BOARD FOR MITSUBISHI OUTLANDER 13+
NOTICE:
The figures here are for reference only and may have differences with the actual product you received,
however they share the same assembly way.
Please read the instruction completely for easy installation, which will also help you to avoid scratches or
other potential damages to your appealing car.
Please periodically check and retighten all
Page 1 of 8
INSTALLATION INSTRUCTION
PARTS LIST
NO.
QTY
PIC.
NO.
QTY
Front bracketL/R
Middle bracketL/R
PIC.
Clamp bracket
Rear bracketL/R
T-bolt M8
T-bolt M8 nut
Page 2 of 8
INSTALLATION INSTRUCTION
12
10
16
11
18
Hex nut4.8M8
12
18
Spring washerD8
Flat washer D8
INSTALLATION STEPS
Page 3 of 8
INSTALLATION INSTRUCTION
INSTALLATION STEPS
Step 1: Check all the contents are available in accordance with the above list.
Setp 2: install running board
1 Find fitting holes
Fig 1
Front
Find
front,
middle and rear
hole
2 Loosely attach the bracket and confirm the fitting position, cut one gap for the conflict area between
clamp and side skirt just cut gap NOT cut though and remove
Fig 2
Page 4 of 8
INSTALLATION INSTRUCTION
Fig 3
inset
5 T-bolt M8 into
the hole and fit bracket
with
10 Hex nut4.8M8
11
Page 5 of 8
INSTALLATION INSTRUCTION
Fig 4
Bracket must install on turn
up edging
4as fig5, install middle bracket, similar to install front bracket, but insert
6 T-bolt M8 nut
into the hole, and then put the bracket and tighten it with
8 hex thread M8_30
11 flat washerD8 and
12 spring
washer D8.
Page 6 of 8
INSTALLATION INSTRUCTION
Fig 5
5as fig5, install rear bracket, similar to install front bracket, but insert
5 T thread M8 into the hole,
and then put the bracket and tighten it with and then use
10 Hex nut4.8M8
11 Flat washer D8 and
12
Spring washerD8 to tighten it, do not to tighten all now. Use same way to install clamp bracket.
Page 7 of 8
INSTALLATION INSTRUCTION
Fig 6
6Align and attached running board to the brackets. Align, level and tighten all spare parts. Repeat steps for the
other side. Installation finished.
DISCLAIMER: We are not responsible for any quality problems caused by improper installation and use.
Page 8 of 8