Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Hi PJ,
My Nortel 425-24T switch is prompting as below. Once the switch is started after pressing a run
agent code manually. When I restart It will start properly. But during each power cycle it is
prompting for a run agent code, d download agent code etc.Please help.
I have tried resetting switch & Upgrading Firmware + Diagnostic also but no result found. It is
behaving on the same way.
Output during power re-cycle are as below :
Ethernet Switch 425-24 Diagnostics 3.6.0.1
Testing main memory PASSED
Resets: 226.
Initializing Flash..
Reading MAC Address..
MAC Address: 00:1B:BA:XX:XX:XX
Initializing Switch CBs
Initializing Switch HW..
Board Revision: 0
Board Variation: 0
Manufacture Revision: 33
Manufacture Date: 05162007
Serial Number: LBNNTMJXXXXXX
MAC Address: 00:1B:BA:XX:XX:XX
GBIC Type [25]: (none)
GBIC Type [26]: (none)
Stack In Cable: (none)
Stack Out Cable: (none)
Stack Base Switch: OFF
Type: Address: Name:__________ Version:
DIAG 00000000 425 Diags 3.6.0.1
AGENT 00100000 425/325 AGENT 3.6.2.014
Test 102 ROM Config PASSED
Test 104 FANs PASSED
Test 207 DRAM Cached/Uncached PASSED
Test 211 PCI Bridge Registers PASSED
Test 221 PHYs Register PASSED
Test 233 SOC XRAM Adr/Data Lines PASSED
Test 241 Link Status Interrupt PASSED
Test 242 SNMP-DMA Interrupt PASSED
Test 251 Ports Internal Loopback PASSED
2222222
2
e show keyboard combinations like this: Ctrl+a. If
the command requires you to
type an uppercase letter, the combination will show
this: Ctrl+Shift+a.