Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Getting Started
Symmetry
Intersection
Split/Trim
Projection
Offset
Affinity
DASSAULT SYSTEMES S.A. 1999
Wireframe
Sketcher
Loft
Sweep
Fillet
2)
Create Point.1
type Coordinates
X=Radius_In
(Edit Formula in
contextual menu)
Y=Z=0mm
3) Create
Symmetry.1,
Element: Point.1
Reference: yz plane
DASSAULT SYSTEMES CONFIDENTIAL INFORMATION
Circle.2
Center: Point.3
Point: Symmetry.1
Support: xy plane
Start:0deg
End: 45deg
6) Create Circle.3
type two point and a radius
Point 1: Symmetry.1
Point 2: Point.1
Support: zx plane
Radius=Radius_In
Circle.1
Center: Point.2
Point: Point.1
Support: xy plane
Start:0deg
End: 100deg
7) Create Sweep.1
type: Explicit
Guide curve: Circle.2
Profile: Circle.3
Spine: no selection
Second guide: Circle.1
Positioned profile: ON
Point: Point.4
(then inverse the direction arrow)
angle: -55deg
start 0mm, end 200mm
GSM: Getting Started
Surface: xy plane
Point: Point.4
Start 0mm, end 10mm
24) Go in the zx
plane sketcher,
create Sketch.1. Put
a coincidence
constraint between
the low extremity of
the sketch and
Point.1
Create Sweep.3
type Explicit,
Guide curve: Join.2
Profile: Symmetry.3
27) Create Split.2 by cutting
Sweep.2 with plane.1, and
create Split.3 by cutting
Sweep.3 with Plane.1
DASSAULT SYSTEMES CONFIDENTIAL INFORMATION
10
MODIFICATIONS TASKS
29) If not done, go in the Tools/Options panel, and choose manual update in
General menu.
Edit the Radius_In parameter: make it equal to 15mm
Edit Line.2: change angle=-55deg to -60deg
Edit Point.4: key in its new coordinates (80,0,0)
Edit Sketch.1: change constraint of 10mm to 15mm , and constraint of 3mm
to 5mm
11