Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
IP Address: 192.168.1.20
255.255.255.0
Connection: 192.168.180.130
255.255.255.0
192.168.180.2
By default accounts without passwords are restricted from logging in via remote desktop (they are limited to
console logins only). You can override this by following the steps below:
To configure the Remote Desktop host computer to accept user name with blank password, go to Control Panel
-> Administrative Tools (Under System and Maintenance in Windows Vista) -> Local Security Policy. Alternatively,
run GPEdit.msc (Group Policy Editor).
Then, expand Security Policies -> Local Securities -> Security Options (for user using Group Policy Editor or
GPEdit.msc, expand Local Computer Policy -> Computer Configuration -> Windows Settings -> Security Settings
-> Local Policies -> Security Options). Locate Accounts: Limit local account use of blank passwords to console
logon only policy, and set its value to Disabled.
You can disable blank password restrictions by using a policy. To locate and change this policy:
1.
Click Start, point to Run, type gpedit.msc, and then click OK to start the Group Policy Editor.
2.
Open Computer Configuration\Windows Settings\Security Settings\Local Policies\Security
Options\Accounts: Limit local account use of blank passwords to console logon only.
3.
Double-click Limit local account use of blank passwords to consol logon only.
4.
Click Disabled, and then click OK.
5.
Quit Group Policy Editor.
Microsoft offer solution of above problem, you need to setup a user account with a password to establish connection with
remote desktop tool. So log on at the console of the computer, and then set a password for that user account.
Actually this behavior is due to Windows password restriction policy. So if you wish to establish connect which have null
password then you need to disable password restriction policy. You can follow the steps as given below to disable restriction
policy.
1.
2.
Click Start, point to Run, type gpedit.msc, and then click OK to start the Group Policy Editor.
Open Computer Configuration\Windows Settings\Security Settings\Local Policies\Security Options\Accounts: Limit
local account use of blank passwords to console logon only.
3.
Double-click Limit local account use of blank passwords to console logon only.
4.
5.
remote desktop tool then there will be no connection created, in this situation you have to apply Windows password
recovery method.
NAT Settings : Host Port: 9997 open linux terminal use the command : ifconfig note the IP Address that address
should pass to Virtual Machine IP Default Port is : 3389