Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
HRCPLX - Computes and stores in the database the timeharmonic solution at a prescribed phase angle.
HREXP - Specifies the phase angle for the harmonic analysis
expansion pass.
HROPT - Specifies harmonic analysis options.
HROCEAN - Perform the harmonic ocean wave procedure
(HOWP).
HROUT - Specifies the harmonic analysis output options.
X. I Commands
IC - Specifies initial conditions at nodes.
ICDELE - Deletes initial conditions at nodes.
ICLIST - Lists the initial conditions.
/ICLWID - Scales the line width of circuit builder icons.
/ICSCALE - Scales the icon size for elements supported in the
circuit builder.
*IF - Conditionally causes commands to be read.
IGESIN - Transfers IGES data from a file into ANSYS.
IGESOUT - Writes solid model data to a file in IGES Version
5.1 format.
/IMAGE - Allows graphics data to be captured and saved.
IMAGIN - Forms an imaginary variable from a complex
variable.
IMESH - Generates nodes and interface elements along lines
or areas.
IMMED - Allows immediate display of a model as it is
generated.
IMPD - Calculates the impedance of a conductor at a
reference plane.
INISTATE - Defines initial state data and parameters.
*INIT - Initializes a vector or dense matrix.
/INPUT - Switches the input file for the commands that
follow.
/INQUIRE - Returns system information to a parameter.
INRES - Identifies the data to be retrieved from the results
file.
INRTIA - Specifies "Inertial loads" as the subsequent status
topic.
INT1 - Integrates a variable.
INTSRF - Integrates nodal results on an exterior surface.
IOPTN - Controls options relating to importing a model.
IRLF - Specifies that inertia relief calculations are to be
performed.
IRLIST - Prints inertia relief summary table.
*ITENGINE - Performs a solution using an iterative solver.
XI. J Commands
JPEG - Provides JPEG file export for ANSYS displays.
JSOL - Specifies result items to be stored for the joint
element.
XII. K Commands
K - Defines a keypoint.
XXV. X Commands
XFDATA - Defines a crack in the model by specifying nodal
level set values
XFENRICH - Defines parameters associated with crack
propagation using XFEM
XFLIST - Lists enrichment details and associated crack
information
/XFRM - Controls the centroid or the axis of dynamic
rotation.
/XRANGE - Specifies a linear abscissa (X) scale range.
XVAR - Specifies the X variable to be displayed.
XXVI. Y Commands
/YRANGE - Specifies a linear ordinate (Y) scale range.
XXVII. Z Commands
/ZOOM - Zooms a region of a display window.