Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Figure 1: d2 1.2.3.4
0 JCManalo
201212692
Figure 2: d2 1.3.1.3
QUESTIONS:
A.Which module provides the most Ethernet ports? How many ports does it provide?
Ang nag-provide ng apat na switching ports ay yung HWIC-4ESW.
B.Which module provides the most Serial ports? How many ports does it provide?
To remote sites or legacy serial network devices such as Synchronous Data Link Control (SDLC) concentrators, alarm systems, and packet over SONET (POS) devices,
ang WIC-1T ay nag provide ng single port na serial connection.
C. Which network module provides the most Ethernet ports? How many ports does it
provide?
Ang NM-ESW-161 provides the most Ethernet ports at nag-provide ng 16 switching
ports.
D. How many empty interface card slots (smaller slots) are available?
0 JCManalo
201212692
Figure 3: d2 2.3.1.3
REFLECTION:
A.What else could have caused connectivity problems on this network?
0 JCManalo
201212692
Ang naging problema kung kaya yung PC-PT 1A ay hindi nag-connect sa server
ay dahil walang Default Gateway address yung PC-PT 1A at maaari ding cause ng
problem ay iba yung IP address na nilagay sa router.
Figure 4: d2 3.1.3.2
0 JCManalo
201212692
Figure 5: d2 3.3.3.4
QUESTIONS:
A. Which interface is available on the router to connect to the new switch? and What
type of cable is required?
Pwedeng gamitin ang PT-ROUTER-nm-1cfe at PT-ROUTER-nm-1ss para sa bagong
switch connection at required na gamitin naman sa cable ay ang Copper straight.
B. What interface is available on the Linksys 300N to connect to the new switch? and
What type of cable is required?
Para naman dito,pwedeng gamitin sa linksys ang PT-ROUTER-NM-1CE(for Linksys)
para sa connection ng bagong switch, at copper cross-over naman ang para sa cable.
0 JCManalo
201212692
Figure 6: d2 3.3.4.3
Figure 7: d2 4.1.3.5
QUESTION:
How many bits must be left for host addresses?
Host-A:12
REFLECTION:
A. How many subnets are still available for future expansion?
74 subnets are still available for future expansion.
B. What would be the two subnet addresses if the host requirement was 80 hosts per
LAN?
The two subnet addresses is 255.255.255.128 and 255.255.255.192.
Figure 8: d2 4.1.5.2
QUESTIONS:
A. Were the ping attempts successful?
No
B. Is myPC in the same subnet as myServer, or the FastEthernet 0/0 interface of
myRouter?
Yes
REFLECTION:
A. Why was myPC unable to communicate with myServer at the beginning of this
activity?
Because myPC ay meron lang 32 host address samantalang yung myServer ay meron
lang na 12 host address.
B. This exercise demonstrates how subnetting affects which devices can communicate
on a network. What does this mean for IP address planning when upgrading a network?
Dapat pantay lang yung subnet sa bilang nung host adrdress. If there is greater
subnet, there must be also greater number of host address provides.
Figure 9: d2 4.2.3.3
QUESTIONS:
A. In the PDU Information at Device: Customer PC window, which IP address is
Customer PC attempting to find a MAC address for?
192.168.1.10
B. In the Event List window, click Capture/Forward twice. Which device answers the
ARP request from Customer PC? Which MAC address is placed inside the ARP reply?
Ang customer switch ay yung device that answers the ARP request mula customer
pc. There is no MAC address placed inside the ARP reply.
0 JCManalo
201212692
10
REFLECTION:
A. List two Cisco IOS CLI commands that are available from the CustomerRouterNo.
prompt that are not available from the CustomerRouterprompt.
The reload and conf command ay hindi available sa CustomerRouterPrompt but
available naman sa CustomerRouterNo.
B. What does (cr) indicate at the end of a list of commands after you have requested
help?
(cr) means that walang ibang parameters would be able in CLI.
0 JCManalo
201212692
11
12
0 JCManalo
201212692
13
REFLECTION:
A. When you ping the LAN IP address of the ISP router, what happens and why?
Pag pini-ping yung connection ng LAN IP address ng ISP router may lalabas na
Request time out, it means failed kase yung configuration ng CustomerRouter hindi
pa nakaset.
B. Which Cisco ISO CLI mode do you need to be in to configure the description of an
interface?
To configure the description of an interface ang kailangang gamitin ay yung CustomerRouter(configif)No.
C. You configured the Fast Ethernet 0/0 interface with the no shutdown command and
verified the configuration. However, when you rebooted the router, the interface was shut
down. You reconfigured the Fast Ethernet 0/0 interface and verified that the configuration
works. Explain what most likely happened.
Sigruo na-delay lang, yung tinatawag natin na time consumption kase it needs time
para mag-work.
0 JCManalo
201212692
14
REFLECTION:
A. Is this type of access to the ISP LAN likely to happen in the real world?
in my opinion, it will not happpen in real world.
B. Why has the student lab been configured to allow this type of access?
For us to know yung iba pang type of access na available.
0 JCManalo
201212692
15
Objectives:
Configuring a Cisco Router as a DHCP Server
16
Objectives:
Configure the customer Cisco 1841 ISR to use NAT.
0 JCManalo
201212692
17
18
REFLECTION:
A. How could CDP be used to troubleshoot network connectivity issues?
The CDP o ang Cisco Discovery Protocol ay ginagamit para malaman ang mga
connectivity issues regarding sa particular network.
B. Is it likely that an ISP would have CDP configured on their gateway router?
Yes, CDP ay maaaring i-enable globally to thenetwork kaya, it can configured on
their gateway router.
0 JCManalo
201212692
19
20
REFLECTION:
A. What is the significance of the enable secret command compared to the enable
password?
The command enable secret ay ginagamit para sa pag se-set ng password for the
priviledged administrative access to the Cisco IOS System, mas secure na gamitin
compare to enable command. Kase yung enable command ay gumagamit ng weak
encryption algorithm kaya mas madali ma-hack.
B. If you want to remove the requirement to enter a password to access the console,
what commands do you issue from your starting point in privileged EXEC mode?
The command that I will be issue ay ang Line Interfae command.
0 JCManalo
201212692
21
REFLECTION:
A. How could CDP be used to troubleshoot network connectivity issues?
Ang CDP o ang Cisco Discovery Protocol ay ginagamit to know all the connectivity
issues regarding sa particular network.
B. Is it likely that an ISP would have CDP configured on their gateway router?
Yes, CDP can configured on their gateway router dahil it can enable globally sa mga
networks.
0 JCManalo
201212692
22
REFLECTION:
A. What are the benefits of using the PPP encapsulation type instead of the default
HDLC?
HDLC is a simple protocol that is used sa pagko-connect ng point-to-point serial
device ant its default WAN protocol while PPP is used for most every dial up connection sa Internet na gumagamit of more sub-protocols and it is feature-rich with
dial up networking features.
0 JCManalo
201212692
23
0 JCManalo
201212692
24
REFLECTION:
A. Why would you install a firewall on the internal network?
Firewall is a software or hardware that checks information coming from the internet
or a networkand then either blocks it or allows it to pass through to your computer,
depending on your firewall settings. Through the use of firewall, tumutulong ito
sa pag-prevent ng mga hackers or malicious software from gaining access to your
computer through a network or the Internet. A firewall can also help stop your
computer from sending malicious software to other computers.
B. How does a router that is configured to use NAT help to protect computer systems
on the inside of the NAT router?
There are higher security level sa pagconfigure ng isang router sa paggamit ng NAT.
C. Examine the location of Firewall 1 and Firewall 2 in the completed network topology.
Which networks are considered trusted and untrusted for Firewall 1? Which networks
are considered trusted and untrusted for Firewall 2?
The trusted network ng Firewall 1 ay ang PC C and the untrusted network ay ang
PC B. The trusted network of Firewall 2 naman is yung PC B while ang untrusted
naman ay ang PC C.
0 JCManalo
201212692
25
201212692
26
27
0 JCManalo
201212692
28
0 JCManalo
201212692
29
REFLECTION:
A. Why cant PC0 communicate with PC1 but PC1 can communicate with PC0s
default gateway?
PC0 cant communicate to PC1 is because of Protocol Data Unit ay ginagamit lang
sa distibution ng connection.
B. What effect on connectivity would removing the subinterfaces have?
Ang pagtanggal sa subinterface ay magre-resulta sa pagkawala ng connection ng
bawat isa dahil ito ay ang gingamit bilang default gateway.
C. Why must a router be in the topology to have communication between the VLANs?
Ang router yung nagbibigay ng connection in every device at ito rin yung responsible
sa pagko-combine nung LAN ports.
0 JCManalo
201212692
30
31
0 JCManalo
201212692
32
0 JCManalo
201212692
33