Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
of Printed Pages 4
CE-405
(b) Determine the position of
Roll No.
400mm
section
5mm
B. TECH.
of
and
CE-405
800mm
5mm
5mm
STRUCTURAL ANALYSIS I
thick (Fig.-4).
5mm
400mm
Fig.-4
Time : 3
Hours
Note : (i)
(ii)
(iii)
(iv)
1.
5 x 4 = 20
10mm
5kN
160mm
(ii)
(iii)
(iv)
hinge
hinge
10mm
10mm
B
A
80mm
Fig.-5
Fig.-1
P.T.O.
CE-405
CE-405
(c) Find the thrust in a two hinged parabolic arch of rise 12m and span
60
60
60
30
'x' from the crown and determine the bending moment at the crown.
C
10kN
Fig.-2
2.
15kN
4.
5 x 4 = 20
10 x 2 = 20
(b) Find the slope and deflection at the free end of a cantilever beam
carrying a load of 15kN at the free end. The span of beam is 6m.
m.
udl of 40kN/m, 5m long moving from left to right on the span. Draw
the unit load method, calculate the deflection under the load point.
m.
left end and calculate the maximum bending moment at this section.
(d) Two point loads 100kN and 200kN spaced 3m apart cross a S.S.
girder of span 20m from left to right with 100kN load leading. Draw
the influence line for shear force and find the value of maximum
shear force 6m from left hand support.
5.
(a) A steel tube of 40mm outer diameter and 25mm inner diameter is
bent in the form of quadrant of 1.6m radius. One end is rigidly fixed
to the horizontal base and the free end supports a load of 800N
(e) Determine the maximum positive and negative shear force and
bending moments at a section 1.5m in a simply supported beam of
(Fig.-3). Find the vertical and the horizontal deflections of the free
6
span 4m, when a concentrated load of 20kN rolls across the beam.
(f)
3.
10 x 2 = 20
25mm 40mm
Explain how the influence line diagram is drawn for plane trusses.
10 x 2 = 20
(a) Define an Arch? How an arch differs from beam? Explain the
800N
1.6m
Fig.-3
carries a udl of 'w' per unit horizontal length on the left half span.
Determine the horizontal thrust at the supports and the maximum
bending moment with its location on the arch.
2
P.T.O.