Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Code: GL.01.NOC.01/BSS
Effective Date:
No
Page
Change Content
PREPARED BY
Signature
CHECKED BY
Release: 01
Page: 1/7
Effective Date
APPROVED BY
Code: GL.01.NOC.01/BSS
Effective Date:
I.
Release: 01
Page: 2/7
PURPOSE
1. This describes how to reset the BSC Standby Board, the CPU on the XPUa
Board, and the DSP on the DPU Board.
II.
SCOPE
REFERENCES
1. HEXDEX
IV.
PREREQUISITES
1. The Boards are in position.
V.
CAUTION
1. Do Not reset the Active Board.
2. If the Standby Board is Not Available or the Standby Board is Faulty, Resetting
the Board will disrupt the Ongoing Services. Thus, perform this operation with
caution.
3. Resetting the board may affect the Ongoing Services. Therefore, you are
advised to perform the Switchover when the traffic load is light, for example,
in the middle of the night.
4. Do not perform data configuration within 10 to 15 seconds after Resetting of
the Board; otherwise, data inconsistency may occur.
5. Reset the CPU: Each XPUa board has eight CPUs numbered from 0 to 7. Other
types of boards have one CPU each. If CPU 0 of the XPUa Board is reset, the
entire Board is reset.
6. Resetting the DSP: Each DPU board has 28 DSPs numbered from 0 to 27. Each
DSP can be reset separately.
Code: GL.01.NOC.01/BSS
Effective Date:
GUIDELINE: RESETTING THE BSC BOARD
VI.
Release: 01
Page: 3/7
FLOWCHART
Start
Reset the
Standby Board
Check the
Standby Board
Yes
Finish
VII.
PROCEDURE:
1. Reset Standby Board
a. Through Menu operations:
No
Code: GL.01.NOC.01/BSS
Effective Date:
Release: 01
Page: 4/7
Code: GL.01.NOC.01/BSS
Effective Date:
Release: 01
Page: 5/7
Code: GL.01.NOC.01/BSS
Effective Date:
Release: 01
Page: 6/7
Code: GL.01.NOC.01/BSS
Effective Date:
Release: 01
Page: 7/7
END