Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14. Which method is suitable for the measurement of resistivity of good conductors of electricity ?
A. Loss of charge method.
B. Kelvin's double bridge method.*
C. Schering's bridge method.
D. Any of the above.
15. De Sauty's bridge best suited for
A. capacitors with dielectric loss.
B. loss less air capacitors.*
C. high Q.
D. low Q.
16. Time taken for the response to raise from zero to 100 % for very first time is called
A. rise time.*
B. settling time.
C. delay time.
D. peak time.
17. Name test signals used in time response analysis?
A. Unit step.
B. Unit ramp.
C. Impulse.
D. All of the above*
18. For lead compensator pole lies
A. on LHS before zero.* B. on origin.
C. on LHS.
D. on RHS.
19. The amplitude spectrum of a Gaussion pulse is
A. uniform.
B. a sin function.
C. Gaussion.*
D. impulse function.
20. A system of constant voltage and constant frequency is called ....... system.
A. feedback.
B. infinite.*
C. zero.
D. none of the above.
21. A 250 V DC generator in run at rated speed with no excitation. The open circuit voltage will be
A. zero.
B. about 100 V.
C. very small, say about 2 or 3 V.*
D. 250 V.
22. With the increases in field excitation of a DC generator, its generated emf
A. decreases.
B. increases.
C. remains constant.
D. increases upto a limit and then remains almost constant.*
23. The horse power obtained from the motor shaft is called the
A. Usefull output.
B. IHP.
C. BHP.*
D. None.
24. In a DC motor if the brushes are given a backward shift then
A. Commutation is improve.
B. Commutation is worsend.
C. Speed increase.
D. Both A and C.*
25. Minimum allowable dielectric strength or break down voltage of power transformer insulating
oil is generally taken as
A. 30 kV.*
B. 40 kV.
C. 50 kV.
D. 60 kV.
26. If supply frequency of a transformer is 50 Hz, its magnetostriction frequency would be
A. 25 Hz.
B. 200 Hz.
C. 50 Hz.
D. 100 Hz.*
27. Noise of transformer mainly due to
A. magnetostriction in iron core.*
B. noise generated by cooling fans.
C. mechanical vibration of different parts of transformer. D. all of above.
28. The ideal shape for the cross section of transformer core is
A. triangle.
B. rectangle.
C. circle.*
D. pentagon.
29. The injected emf in the rotor of induction motor must have
A. A high value for satisfactory speed control.
B. The same frequency as the slip frequency.*
C. The same phase as the rotor emf.
D. The same phase as the rotor emf and a high value for satisfactory speed control.
30. The advantage of the double squrrel cage induction motor over a single cage rotor is that its
A. Slip is higher.
B. Efficiency is higher.
C. Starting current is lower.*
D. Power factor is higher.
46. The main reason for the connecting of a pulse transformer at the output stage of the thyristor
triggering circuit is to
A. amplify the power of the triggering pulse.
D. both B and C.
D. all of these.
49. Under over voltage condition impedance offered by the voltage clamping device is
A. high.
B. low.*
C. moderate.
D. infinity.
50. What is used to protect a thyristor from high di / dt conditions?
A. Fuse.
B. Snubber circuit.
C. Inductor.*
D. Voltage clamping device.
51. Air blast circuit breaker is most suitably used in
A. up to 132 kV line.
B. up to 260 kV line.
C. up to 400 kV line.*
52. Mho relay is used for the protection of
A. long transmission lines.*
D. any voltage.
B. short length lines.
D. None of these.
D. 4.
56. What are the tests performed for oil-filled and gas-filled cables ?
A. Load cycle tests.
B. Thermal stability test.
C. Impulse tests.
D. All of these.*
57. A power station's plant load factor is defined as the ratio of
A. Minimum load to peak load.
C. Average load to peak load.*
D. The energy generated to that maximum energy that could have been generated.
58. Demand factor on a power system is
A. Always lesser than unity.*
C. Normally lesser than unity.
59. The power which must be avalable ever under emergency conditions is known as
A. Hot reverse.
C. Firm reverse.*
B. Cold reverse.
D. Spining reverse.
B. Connected load.
D. Both A and B.*
D. 40%
64. As per recommendation of ISI, the maximum load that can be connected in one sub circuit is
.... watts
A. 800 *
B. 1000
C. 1500
D. 3000
65. Maximum permissible span with wooden poles is
A. 20 m
B. 30 m
C. 50 m*
D. 80 m
66. Which of the following is the major consideration to evolve a good design ?
(a) Cost
(b) Durability
(c) Compliance with performance criteria as laid down in specifications
(d) All of the above *
67. If an insulating material is operated beyond the maximum allowable temperature, its life is
(a) drastically increased
(b) drastically reduced*
(c) unaffected
(d) none of the above
68. The design of mechanical parts is particularly important in case of ....... speed machines.
(a) low
(b) medium
(c) high*
(d) any of the above
69. In induction motors, the length of air gap in kept as small as mechanically possible is order to
have
(a) low power factor
(b) medium
(c) large*
71. An example of secondary battery cell is
A. Edison Alkali cell.*
C. Lachanche cell.
72. What will be the total flux emitted by a source of 60 candle power?
A. 754.2 lumens.*
B. 0.001326 lumens.
C. 60 lumens.
D. None of these.
B. Dynamic braking.
D. Rheostat braking.
D. All of above.*
B. area of plates.
C. thickness of plate.*
D. all of them.
77. If the length of a wire of resistance R is uniformly stretched to n times its original value, what
will be its new resistance
A. n2R.*
C. n2 / R.
B. R / n2.
D. nR .
D. a sine function.
B. subtraction.
C. multiplication.*
D. division
B. frequency*
C. current
D. voltage
B. Mumbai*
C. Kolkata
D. Chennai
C. Tunnel of Time
D. Prison Notes
B. Olive
C. Pine
D. Oak
84. Among the following who introduce Sitar and Kawali in India
A. Miya Tansen
B. Chandra gupta II
C. Samundra Gupta
D. Amir Khusru*
85. Which of the following country does not have a National day or Independence Day ?
A. China
B. Great Britain*
C. France
D. U.S.A